Components: SUSPENSION STRUCTURE
July 15, 2014
TBD
Condition
Unknown
Damage
Collision
Title
Clear
| Dynamic Head Restraints | Not Available |
|---|---|
| Head Restraint | Not Available |
| Advanced Belt Feature | Not Available |
| Adjustable Upper Belt Anchorage | Not Available |
| Seat Belt Reminder System | Not Available |
| Frontal Air Bag | Driver, Front Passenger |
|---|---|
| Curtain | Driver, Front Passenger, Rear Seat |
| Knee | Not Available |
| Additional Air Bags | Not Available |
| Meets Side Air Bag Out-of-Position Requirements | Yes |
| LATCH Locations | Not Available |
|---|---|
| Safety Power Windows (Anti-Pinch) | Not Available |
| Safety Power Windows (Anti-Pinch) locations | Not Available |
| NHTSA ID Number: | 10745048 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | 1FMZU67K54U**** |
TL* THE CONTACT OWNS A 2004 FORD EXPLORER SPORT TRAC. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE FRAME WAS RUSTED AND PARTS WERE FRACTURED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME AND THE FRONT AND REAR MOTOR MOUNTS WERE RUSTED AND NEEDED BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED WITH THE FRONT END MOTOR MOUNT. WHILE DRIVING APPROXIMATELY 40 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRIVER AND PASSENGER SIDE PINION, BARONS, AND SEALS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 78,000. MA 10/23/15 *CN
| NHTSA ID Number: | 10508536 |
|---|---|
| Consumer Location: | PATILLAS, PR |
| VIN: | 1FMZU67K54U**** |
BODY/CHASSIS MOUNTS ARE DETERIORATING AND CRUMBLING. BODY IS NOW LOOSE ON THE FRAME AND HAS SLIGHT MOVEMENT. THESE MOUNTS ARE NOT RUBBER LIKE MOST; THEY ARE SOME SORT OF URETHANE COMPOSITE. INTERNET RESEARCH AND TRUCK OWNER SITES CONFIRM THIS TO BE A COMMON PROBLEM. FORD DOES NOT SEE THIS AS A SAFETY/RECALL ISSUE AND HAS DIRECTED OWNERS OF SUSPECT VEHICLES TO YOUR DEPARTMENT. THIS PARTICULAR VEHICLE HAS NEVER BEEN IN SALT OR SNOW . THE CAB SHAKING AND RATTLING IS CAUSING MOVEMENT THAT WILL UNDOUBTEDLY EFFECT THE BRAKE LINES AND STEERING COLUMN AS THEY ARE ATTACHED TO BOTH THE BODY AND THE CHASSIS. FORD IS NOW USING ANOTHER COMPOUND FOR THE MOUNTS APPARENTLY IN RESPONSE TO COMPLAINTS. *TR
| NHTSA ID Number: | 10379570 |
|---|---|
| Consumer Location: | OAK RIDGE, TN |
| VIN: | 1FMZU67K54U**** |
BEGAN TO NOTICE TRANSMISSION SLIPPING ABOUT 4 MONTHS AGO. FORD ADVISED FLUID CHANGE. FLUID CHANGE DID NOT HELP. PROBLEM IS GETTING WORSE, NOW OCCURS DAILY. MECHANIC SAYS HE CANNOT DUPLICATE PROBLEM AND NO ERROR CODES SHOW UP WHEN TEST IS RUN. THIS PROBLEM IS VERY COMMON FOR THIS VEHICLE BUT THE DEALERSHIPS DO NOT ACKNOWLEDGE IT. PROBLEM CAN RESULT IN ACCIDENT DUE TO NO OR LITTLE ACCELERATION UNEXPECTEDLY. TRANSMISSION REPLACEMENT IS ADVISED AT A COST OF $3500 FOR FORD REBUILT WITH 3 YEAR/36 MONTH WARRANTY. *LN
| NHTSA ID Number: | 10307127 |
|---|---|
| Consumer Location: | EGLIN AFB, FL |
| VIN: | 1FMZU67K54U**** |
I WAS LEAVING MY FRIEND'S HOUSE TO DRIVE APPROXIMATELY 2 MILES AND WHEN I WENT TO PARK MY TRUCK WHICH IS A 2004 FORD EXPLORER SPORT TRAC XLT, THE GEAR SHIFTER WAS VERY LOOSE GOING INTO PARK, BUT DID NOT ENGAGE BECAUSE I WAS STILL ROLLING BACK, I THEN PROCEEDED TO PUT ON THE EMERGENCY BRAKE. I TURNED OFF MY TRUCK AND THEN STARTED IT AGAIN AND THIS TIME MY TRUCK WILL NOT TURN OVER AND THE SHIFTER IS STILL EXTREMELY LOOSE. I LOOKED ON SEVERAL FORUMS AND THEY ALL SAY THAT I MIGHT HAVE TO REPLACE MY STEERING COLUMN, AND AS FAR AS MY TRUCK NOT STARTING, I DON'T KNOW. *TW
| NHTSA ID Number: | 10167719 |
|---|---|
| Consumer Location: | DOUGLAS, AZ |
| VIN: | 1FMZU67K54U**** |
DT*: THE CONTACT STATED WHILE DRIVING 40 MPH THE STEERING WHEEL LOCKED UP AND THE CONTROL OF THE VEHICLE WAS LOST RESULTING IN AN ACCIDENT AND INJURIES. THE RECIRCULATION BALL AND THE RACK AND PINION FAILED CAUSING THE STEERING TO LOCK UP. THE DEALER AND THE MANUFACTURER WERE ALERTED OF THE INCIDENT. THE CONSUMER CAME AROUND A CORNER AND SUDDENLY LOST CONTROL OF THE VEHICLE, THE CONSUMER STATED THE VEHICLE WAS INVOLVED IN AN ACCIDENT 5 MONTHS PRIOR, AND HE BELIEVED THE VEHICLE MAY HAVE NOT BEEN PROPERLY FIXED WHICH MAY HAVE CAUSED THE ACCIDENT. THE CONSUMER ALSO STATED THE AIR DID NOT DEPLOY IN THIS ACCIDENT. THE POLICE CONCLUDED THAT THE CONSUMER WAS TRAVELING TOO FAST FOR CONDITIONS AND UPON ROUNDING THE CORNER, HE LOST CONTROL AND STRUCK THE BANK ON THE SIDE OF THE ROADWAY CAUSING THE VEHICLE TO OVERTURN. THE CONSUMER HAD PREVIOUS REPAIRS ON THE VEHICLE SUCH AS AN INOPERABLE TURN SIGNAL LIGHT AND THE REAR VENTS DID NOT BLOW OUT AIR. UPDATED 10/3/06 *JB UPDATED 10/25/2006 - *NM
| NHTSA ID Number: | 10067405 |
|---|---|
| Consumer Location: | BROWNSVILLE, TX |
| VIN: | 1FMZU67K54U**** |
THE CONSUMER WAS TAKING OFF FROM A STOP WHEN HE NOTICED THAT THE VEHICLE WOULDN'T GO HIGHER THAN 28 MPH. THE VEHICLE WAS TAKEN TO THE DEALER AND THE DEALER COULD NOT DUPLICATE THE PROBLEM. *AK *SC *JB
| NHTSA ID Number: | 11413513 |
|---|---|
| Consumer Location: | MALABAR, FL |
| VIN: | 1FMZU63KX4U**** |
MICHELIN CROSSTERRAIN TIRES SUFFERING TREAD SEPARATION. THREE OUT OF FOUR SO FAR. HAD I NOT BEEN PAYING ATTENTION TO THIS PROBLEM IT WOULD HAVE HAPPENED ON THE HIGHWAY..
| NHTSA ID Number: | 11407982 |
|---|---|
| Consumer Location: | MALABAR, FL |
| VIN: | 1FMZU63KX4U**** |
TIRES! TIRES! TIRES! AGAIN! A SECOND TIRE HAS SUFFERED TREAD SEPARATION AND FAILED COMPLETELY. WHY CAN'T I GET ANYONE TO TAKE THIS PROBLEM SERIOUSLY?
| NHTSA ID Number: | 11395422 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | 1FMDU74W64U**** |
ENGINE DIES WHEN DRIVING WITH CRUISE CONTROL OPERATING AND HEADING DOWN SLIGHT HILL AT SPEED OF AROUND 35 MPH. CRUISE IS DESIGNED TO MAINTAIN DRIVING SPEED GOING DOWN THE HILL (UP OR DOWN HILL FOR THAT MATTER). THE TACHOMETER INDICATES A SLOWING OF ENGINE RPM. AT HIGHER SPEEDS, THE SLOWING OF RPM DOES NOT FALL TOO LOW. HOWEVER, AT THE SLOWER SPEED AROUND 35MPH, THE RPM DROPS BELOW 500 RPM AND THE ENGINE STALLS. I LOSE POWER STEERING AND BREAKS. I HAVE A DIFFICULT TIME STEERING AND BREAKING. THIS IS A SAFETY PROBLEM ON A CURVE OR IF A RED LIGHT IS AHEAD. I CAN'T STEER THE CAR ON THE CURVE. I MAY NOT BE ABLE TO STOP THE CAR AT THE TRAFFIC LIGHT AND END UP IN AN INTERSECTION AND BE HIT BY VEHICLES WITH A GREEN LIGHT. I MAY HIT A CAR IN FRONT OF ME THAT HAS STOPPED AT A LIGHT OR STOP SIGN. I MAY NOT BE ABLE TO STOP FOR A PEDESTRIAN CROSSING AT THE INTERSECTION (WITH THE LIGHT). I MAY NOT BE ABLE TO AVOID A CHILD ... WHO DARTS INTO THE ROADWAY. THIS IS A PROBLEM FOR MANY OWNERS OF THE 2004 EXPLORER. THERE ARE MANY COMPLAINTS ABOUT IT ON THE WEB. IT IS A PROBLEM THAT HAS BEEN NOTED FOR YEARS. I COMPLAINED ABOUT IT TO DEALERS SEVERAL TIMES. DEALERS DISMISSED IT AS NOTHING CAN BE FOUND, REPLICATED OR JUST NOT A PROBLEM. IT IS TIME TO RECALLL THE VEHICLE TO FIX THIS SAFETY PROBLEM. THIS IS AN ONGOING PROBLEM. I TRY TO AVOID USING CRUISE CONTROL CONTROL AT THE 35MPH RANGE. IT SEEMS OK AT HIGHWAY SPEEDS. THE LAST OF MANY INSTANCES WAS IN NOVEMBER 2020. THE PROBLEM FIRST HAPPENED WHEN THERE ABOUT 30,000 MILES ON THE CAR.
| NHTSA ID Number: | 11389077 |
|---|---|
| Consumer Location: | MALABAR, FL |
| VIN: | 1FMZU63KX4U**** |
WHILE DRIVING HOME FROM WORK LAST WEEK I NOTICED A SLIGHT 'BUMPING' FEEL LIKE AN UNBALANCED TIRE, SO I TOOK A LOOK WHEN I GOT TO MY DRIVEWAY BUT FOUND NOTHING. THE NEXT DAY ON MY WAY TO WORK THE "BUMPING' WAS MUCH WORSE SO I STOPPED TO CHECK AND FOUND A LARGE BULGE ON THE TREAD OF THE RIGHT FRONT TIRE. AFTER SLOWLY RETURNING HOME I REMOVED IT AND SET IT ASIDE. A FEW HOURS LATER THE THREADS WERE SEPARATING BADLY SO I LET THE AIR OUT BEFORE IT BLEW APART. I ORDERED A REPLACEMENT TIRE (DIFFERENT BRAND) BUT I'VE STILL GOT THREE MORE OF THESE ON THE VEHICLE .THEY HAVE 36K MILES ON THEM AND A 60K WARRANTY WITH ONLY MODEST THREAD WEAR BUT I STILL CHECK THEM EVERY DAY. I DON'T FEEL SAFE.*DT CONSUMER STATED HE STILL HAS A DEFECTIVE TIRE.*JB
| NHTSA ID Number: | 11337948 |
|---|---|
| Consumer Location: | ANDERSON, SC |
| VIN: | 1FMDU64K04U**** |
THIS PAST WEEKEND I WAS DRIVING AN 04 FORD EXPLORER WHEN BOTH SIDE AIRBAGS SPONTANEOUSLY DEPLOYED. I WAS NOT IN AN ACCIDENT. I WAS DRIVING DOWN A TWO-LANE ROAD AT LESS THAN 35 MILES PER HOUR WHEN THE AIRBAGS DEPLOYED. I WAS ABLE TO PULL OVER BUT NOT BEFORE SUSTAINING AN INJURY TO MY EAR AND NOT BEFORE THE PASSENGER SUSTAINED AN INJURY TO HER RIGHT ARM. I REPORTED THIS TO FORD, WHICH ADVISED TO CARRY THE VEHICLE TO A DEALERSHIP. TOOK IT TO THE DEALERSHIP, WHERE THE SERVICE MANAGER WAS UNCONCERNED WITH THE FACT THAT THE AIRBAGS SPONTANEOUSLY DEPLOYED. HE LOOKED AT THE VEHICLE FOR TWO DAYS ONLY TO REPORT HE WAS NOT AWARE OF WHY THE AIRBAGS DEPLOYED AND STATED THERE WAS NOTHING HE COULD DO ABOUT IT. I REPEAT, I WAS NOT IN AN ACCIDENT AND THE AIRBAGS DEPLOYED WHILE DRIVING. THIS IS OF COURSE QUITE CONCERNING TO ME BUT FORD DOES NOT SEEM TO CARE. PLEASE FOLLOW-UP ON THE SAFETY OF FORD'S VEHICLES.
| NHTSA ID Number: | 11299314 |
|---|---|
| Consumer Location: | KILAUEA, HI |
| VIN: | 1FMZU77K14U**** |
THE BODY OF MY 2004 FORD EXPLORER SPORT TRAC XLT HAS RIVETS ON THE TOP OF THE ROOF THAT HOLD WATER. INSTEAD OF BEING A FLAT SURFACE WHERE RAIN CAN NATURALLY FALL OFF THE TOP OF THE ROOF IT SITS IN THESE RIVETS AND ACCUMULATES RUST. THIS LEADS TO A LOT MORE PROBLEMS.
| NHTSA ID Number: | 11286314 |
|---|---|
| Consumer Location: | HADDAM, CT |
| VIN: | 1FMDU74W04U**** |
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE WHEEL STUDS DETACHED ON MULTIPLE TIRES WHILE DRIVING. THE FAILURE RECURRED THREE TIMES ON MULTIPLE WHEELS ON DIFFERENT OCCASIONS. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN ONCE TO AN INDEPENDENT MECHANIC WHERE THE STUDS WERE REPLACED; HOWEVER, THE FAILURE CONTINUED. THE CONTACT ALSO STATED THAT SHE REPLACED MULTIPLE STUDS HERSELF. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
| NHTSA ID Number: | 11267598 |
|---|---|
| Consumer Location: | HUBERT, NC |
| VIN: | 1FMVU77KX4U**** |
TL* THE CONTACT OWNS A 2004 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE DRIVER AND FRONT PASSENGER SEAT BELTS FAILED TO RETRACT AND LOCK IN POSITION. THE CONTACT CALLED SANDERS FORD (LOCATED AT 1006 W CORBRELT AVE, SWANSBORO, NC 28584, 910-326-1801) AND WAS INFORMED THAT THE SEAT BELTS WERE NO LONGER COVERED UNDER WARRANTY; THEREFORE, THE CONTACT WOULD BE RESPONSIBLE FOR THE DIAGNOSTIC AND REPAIR COST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. THE VIN WAS INVALID.
| NHTSA ID Number: | 11267608 |
|---|---|
| Consumer Location: | HUBERT, NC |
| VIN: | 1FMZU77KX4U**** |
SEATBELT MECHANISM FOR DRIVER SIDE AND PASSENGER SIDE IS INOPERABLE. IT DOESN'T LOCK AFTER YOU PUT YOUR SEATBELT ON. THE MECHANISM YOU PUT THE SEATBELT BUCKLE IN IS GOOD BUT AFTER THAT THE LOCK MECHANISM FOR THE BELT TO RETRACT ISN'T WORKING PROPERLY. IT DOESN'T MATTER IF YOU ARE DRIVING OR PARKED.
| NHTSA ID Number: | 11267173 |
|---|---|
| Consumer Location: | LEMON GROVE, CA |
| VIN: | 1FMZU67K14U**** |
DURING NORMAL USE, USUALLY WHEN IN MOTION BUT FREQUENTLY WHEN THE VEHICLE IS NOT IN MOTION, THE DRIVERS SEAT SUDDENLY FLOPS BACKWARDS TO THE RECLINE POSITION. THIS HAS BEEN AN ISSUE SINCE THE TRUCK WAS ABOUT THREE YEARS OLD. I TOOK IT TO THE DEALER ONE TIME BUT THEY SAID THEY WOULD HAVE TO KEEP THE TRUCK; THAT DIDNT WORK FOR ME BECAUSE I WOULD HAVE NO TRANSPORTATION AND I ALWAYS HAVE TO GO TO WORK, THEN AND NOW. I SAW A RECALL ON THE 2010 FOR THIS AND FIGURED I WOULD LET YOU KNOW IT WAS FOR A LOT LONGER THAN THAT. IT MIGHT HELP EXPLAIN SOME DEAD PEOPLE IN SPORT TRACS. I CERTAINLY HAD SOME ANXIOUS MOMENTS AT TIMES IN THE 15 YEARS WITH MY TRUCK..IVE TRIED TO FIX IT SEVERAL TIMES WITH NO REAL SUCCESS, A NEW SEAT IS EXPENSIVE, USED SEATS ARE GOING TO DO THE SAME THING BUT SINCE MY SEAT HAS ALSO COLLAPSED I GUESS I NEED TO REPLACE IT.
| NHTSA ID Number: | 11265739 |
|---|---|
| Consumer Location: | SAINT JOHNS, FL |
| VIN: | 1FMDU74W74U**** |
THE VEHICLE WAS MOVING AT A SLOW RATE OF SPEED (APPROX 5-10 MPH) ON A BUMPY ROAD. THE DRIVER WAS LOOKING FOR A PARKING SPACE. THE SIDE AIRBAGS DEPLOYED. THE INSURANCE COMPANY HAS DETERMINED THAT THERE WAS NO COLLISION OR REASON FOR THE AIRBAGS TO DEPLOY AND THEREFORE THEY WILL NOT COVER THE DAMAGE.
| NHTSA ID Number: | 11258464 |
|---|---|
| Consumer Location: | OAKLAND, CA |
| VIN: | 1FMZU63K94U**** |
MY 2004 FORD EXPLORER HAS RECENTLY AND QUICKLY BEGAN SHIFTING VERY BADLY. I ALWAYS COME TO A COMPLETE STOP AND SHIFT INTO NEUTRAL BEFORE SHIFTING INTO REVERSE OR DRIVE BECAUSE WHEN SHIFTING INTO REVERSE FROM P OR D, IT ALWAYS TAKES A WHILE, THEN CLUNKS AGGRESSIVELY INTO PLACE. WHILE DRIVING SOMETIMES DOWNSHIFTING WILL ALSO CLUNK INTO PLACE. THIS ISSUE HAS BEEN REPORTED BY COUNTLESS OTHER DRIVERS AND HAS CAUSED MANY POTENTIALLY DANGEROUS SITUATIONS. FROM ACCELERATING SLOWLY THEN BANGING GEARS AND TAKING OFF, TO STUTTERING WHILE TRYING TO ACCELERATE, OR EVEN SWITCHING INTO REVERSE WHILE PARKING, AND HAVING THE CAR TRY TO JUMP BACK A FEW INCHES IS ONLY A FEW ISSUES THIS PROBLEM HAS CAUSED MYSELF AND COUNTLESS OTHERS. PEOPLE ARE REPLACING TRANSMISSIONS LEFT AND RIGHT TO NO AVAIL, ONLY A FEW 10 THOUSAND MILES AFTER INSTALLING NEW TRANSMISSIONS, THEIR CAR STARTS TO EXPERIENCE THE SAME ISSUES AS BEFORE. AT LOW SPEEDS AND IN PARKING LOTS THIS BECOMES A GAME OF LUCK AS YOU ACCELERATE MORE THAN NECESSARY TO TRY TO GET GOING, THEN STOPPING AND WAITING A FEW SECONDS WHILE YOU SHIFT TO NEUTRAL BEFORE SHIFTING TO REVERSE AS FEAR OF IT BANGING INTO GEAR AS YOU TRY TO MANEUVER YOUR CAR AROUND PEOPLE AND OTHER PARKED CARS BECOMES A MORE DANGEROUS TASK THAN IT SHOULD BE. IN SUM, WHILE STATIONARY, SLOW SPEED, OR JUST CRUISING, THE TRANSMISSION WHILE SHIFTING GEARS, OR SHIFTING INTO REVERSE/DRIVE, SOMETIMES WANTS TO BANG INTO GEAR OR LOSE POWER, OR DELAY SHIFTING ONLY TO BANG INTO GEAR MOMENTS LATER. SOME ISSUES WHEN TAKING CARS INTO REPAIR IS FINDING METAL TRANSMISSION SHAVINGS WHERE THEY SHOULDNT BE! FINALLY, THE EXCESSIVE BANGING CAN ALSO DAMAGE THE ENGINE OVER TIME IN ADDITION TO THE TRANSMISSION. PLEASE REFERENCE THE FOLLOWING LINK TO GET A BETTER IDEA OF THE ISSUES: HTTPS://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2004/TRANSMISSION/TRANSMISSION_SLIPPING_SHIFTS_HARD.SHTML THANKYOU
| NHTSA ID Number: | 11245234 |
|---|---|
| Consumer Location: | RIVERDALE, IL |
| VIN: | 1FMZU73K14Z**** |
THE IGNITION KEYS LOSES THE PROGRAM AND I CONSTANTLY HAVE TO HAVE NOTH REPROGRAMED. I WAS TOLD THIS WAS A RECALL THAT FORD KNOWS ABOUT. THE CAUSE THE CAR INABILITY TO START
| NHTSA ID Number: | 11233554 |
|---|---|
| Consumer Location: | MILLER PLACE, NY |
| VIN: | 1FMZU74W84Z**** |
PLASTICE PARTS ARE DETERIORATING, DESOLVING IN FRONT INSIDE DRIVE SUN VISOR-LIGHTED VISOR BROKE OFF; CENTERL REAR A/C AND HEAT MOON ROOF LIGHT CONSOLE FALLS OFF-PLASTICE CLIPS DESOLVED AND WILL NOT FASTEN INTO ROOF ASSEMBLY, CAUSING BLOCKED EYESIGHT AND AT TIME ON RIGHT TURN HITTING HEAD OR EYES . THIS IS UNSAFE AND FORD MOTOR KNOWS OF COMPLAINST. PART ARE NOT AVAILBLE. THIS IS A HIGHWAY SAFETY ISSUE. THE MODEL WAS THE EDDIE BAUER TOP OF THE LINE $40,,835 CAR FMV $5000 ONLY 54000 MILES PRI LEVEL CODE 450240U74 SHIP WGT 4357
| NHTSA ID Number: | 11228959 |
|---|---|
| Consumer Location: | JASPER, TX |
| VIN: | 1FMFU17L14L**** |
TL* THE CONTACT OWNS A 2004 FORD EXPEDITION. THE CONTACT STATED THAT THE BRAKE LAMPS, TURN SIGNALS, AND EMERGENCY FLASHERS FAILED TO OPERATE PROPERLY. THIS WAS A DISTRACTION TO THE CONTACT'S DRIVING BECAUSE HE COULD NOT NOTIFY OTHER DRIVERS OF THE VEHICLE'S MOVEMENTS. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC, BUT THEY DID NOT HAVE TIME TO DIAGNOSE THE VEHICLE. THE CONTACT CALLED A FORD CUSTOMER SERVICE LINE, BUT THEY DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 264,000.
| NHTSA ID Number: | 11221524 |
|---|---|
| Consumer Location: | UNIONTOWN, OH |
| VIN: | **** |
MY STEERING COLUMN BROKE RIGHT OFF! TRYING TO PUT IT IN DRIVE @99,735 MI. HAD TO TOW IT TO SHOP, AND REPLACE THE STEERING COLUMN. I SEE OTHER PEOPLE HAD THIS SAME PROBLEM. THERE SHOULD BE A RECALL FOR THIS!!! I ALSO HAD TO REPLACE THE TRANSMISSION @ 103,000 MILES IT WOULD SKIP 3RD GEAR. SEEMS EVERYONE ELSE HAS TO REPLACE THE TRANSMISSION. ALSO BACK BEARINGS!! WHAT A DISGRACE. RECALL THIS DISGRACEFUL WORKMANSHIP! NO HONOR!
| NHTSA ID Number: | 11187003 |
|---|---|
| Consumer Location: | BURLINGTON, WI |
| VIN: | 1FMZU67K94U**** |
TL* THE CONTACT OWNED A 2004 FORD EXPLORER SPORT TRAC. WHILE DRIVING 40 MPH IN INCLEMENT WEATHER AND ROAD CONDITIONS, THERE WAS A LOSS OF TRACTION AND STEERING ABILITY. THE VEHICLE SPUN OUT OF CONTROL, ROLLED OVER AT LEAST FIVE TIMES, AND CRASHED INTO A DITCH. THE SEAT BELT RESTRAINED THE DRIVER; HOWEVER, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED EXTENSIVE BRUISING ON THE RIGHT SIDE OF THE BODY, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. MILLER MOTOR SALES INC (1196 MILWAUKEE AVE, BURLINGTON, WI 53105, (888) 449-0974) WAS NOTIFIED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED AND TOWED TO A YARD BY THE INSURANCE COMPANY. THE APPROXIMATE FAILURE MILEAGE WAS 204,000.
| NHTSA ID Number: | 11174673 |
|---|---|
| Consumer Location: | BERKELEY, IL |
| VIN: | 1FMZU73KO4Z**** |
I WAS GETTING STUFF OUT OF MY BACK SEAT AND MY REAR WINDOW JUST BLEW OUT SHATTERING GLASS ALL OVER .THE BOTTOM PIECE THAT SECURES THE GLASS TO THE DOOR WARPRED ABOUT 6 INCHED ON EACH SIDE EXPLODING THE GLASS
| NHTSA ID Number: | 11174477 |
|---|---|
| Consumer Location: | CHESTERFIELD, SC |
| VIN: | 1FMZU63W74U**** |
I HAVE CRACKS IN THE PLASTIC ON THE OUTSIDE OF MY LIFT GATE . EACH TIME I USE THE HANDLE TO LIFT THE CRACKS BECOME WORSE. THERE ARE SEVERAL POSTS ONLINE ASKING ABOUT THE SAME PROBLEM. EVERY ONE I SEE IN A PARKING LOT OR ON THE ROAD HAS THE SAME PROBLEM. FORD REPORTS THAT IT AFFECTS 1997-2007 EXPLORERS. I DON'T UNDERSTAND WHY THIS HASN'T BEEN ADDRESSED. I CALLED FORD AND THEY REFERRED ME TO YOUR ORGANIZATION. SOME OF THESE CRACKS I HAVE SEEN REACH TO THE BACK WINDOW WHICH I BELIEVE WOULD BE A SAFETY HAZARD.
| NHTSA ID Number: | 11170037 |
|---|---|
| Consumer Location: | SIMI VALLEY, CA |
| VIN: | 1FMZU63W54Z**** |
TL* THE CONTACT OWNED A 2004 FORD EXPLORER. WHILE THE CONTACT'S SON WAS DRIVING 40 MPH, HE LOST CONTROL OF THE VEHICLE AND STRUCK A TREE, A LIGHT POST, AND AN ELECTRICAL BOX. THE AIR BAGS DID NOT DEPLOY. THE CONTACT'S SON WAS NOT INJURED. A POLICE REPORT WAS FILED AND THE VEHICLE WAS TOWED TO A TOW YARD. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED AND WAS DEEMED A TOTAL LOSS BY THE TOW COMPANY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 291,000.
| NHTSA ID Number: | 11163755 |
|---|---|
| Consumer Location: | WAIPAHU, HI |
| VIN: | **** |
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE DRIVING AND ATTEMPTING TO SHIFT GEARS, THE CONTACT'S SON PULLED TOO HARD AND FRACTURED THE GEAR SHIFTER. THE CONTACT STATED THAT THE GEAR SHIFTER WAS CURRENTLY TOO LOOSE AND WOULD NOT SHIFT INTO ANY GEAR. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
| NHTSA ID Number: | 11150300 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | **** |
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE REVERSING, THE CONTACT'S VEHICLE ACCELERATED ON ITS OWN AND CRASHED INTO A CHEVROLET COBALT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DIAGNOSED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED MULTIPLE TIMES, RESULTING IN THE CONTACT CRASHING INTO A TREE AND OTHER UNKNOWN VEHICLES. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 175,000. THE VIN WAS UNKNOWN. *TT VIN IS NOT VALID *JB
| NHTSA ID Number: | 11145262 |
|---|---|
| Consumer Location: | BREMEN, GA |
| VIN: | **** |
THE DRIVERS SEAT BELT HAS COME UNLOCKED ON SEVERAL OCCASIONS. IT HAS HAPPENED SO MANY TIMES I TUG HARD EVERY TIME I BUCKLE UP TO MAKE SURE IT'S CLICKED AND IT HAS UNLOCKED WHILE DRIVING EVEN THOUGH I DOUBLE CHECK IT.
| NHTSA ID Number: | 11141637 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | 1FMDU74W34Z**** |
BRAKE FAILURE, FRONT WHEEL BRAKE HOSE (BURST/FAILED), 3X IN ONE YEAR INCLUDING FAILURE OF NEW PARTS INSTALLED BY FORD. THIS RESULTED IN TOTAL LACK OF BRAKES, IN ONCE CASE WHILE TRAVELING ON I287 AT HIGH SPEED! THIS WAS IN 20011/2012 BEFORE WE TRADED CAR IN. FORD INSISTED THERE WAS NO PROBLEM WITH THE PART. THE CAR HAD ABOUT 100,000 MILES ON IT, WAS 6-7 YEARS OLD. I HAVE NEVER EXPERIENCED THIS TYPE OF FAILURE ON ANY OTHER CAR I OWNED INCLUDING MANY THAT WERE MUCH OLDER AND HAD MANY MORE MILES ... LET ALONE 3X ON THE SAME VEHICLE! THIS REALLY MUST BE A DEFECTIVE PART!!! AN THE PROBLEM SEEMS TO BE ONGOING WITH NEWER MODELS OF THE FORD EXPLORER AS WELL?
| NHTSA ID Number: | 11132434 |
|---|---|
| Consumer Location: | MILWAUKEE, WI |
| VIN: | 1FMZU77K94U**** |
INSTRUMENT PANEL CLUSTER GAUGES AND ODOMETER DROP TO ZERO AT TIMES WHILE DRIVING, AND I DON'T KNOW MY SPEED AND WELL AS RPM'S. AFRAID THE ENGINE MIGHT SLOW DOWN OR STOP CREATING A POSSIBLE FREEWAY ACCIDENT. ON LINE THERE ARE SEVERAL COMPLAINT ABOUT THIS PROBLEM.
| NHTSA ID Number: | 11118597 |
|---|---|
| Consumer Location: | TUALATIN, OR |
| VIN: | 1FMZU73K74U**** |
I AM HAVING ELECTRONICA ISSUES WITH MY 2004 FORD EXPLORER, THAT CONTROL LIGHTING AND SPEED OF MY VEHICLE. ALSO THE LEFT SIGNAL ARM THAT CONTROLS HIGH BEAMS, AND LIGHTING SNAPPED OFF WHILE I WAS ON THE FREEWAY ON AUGUST 5TH, 2018. THE ELECTRICAL PROBLEM STARTED IN JUNE 2018.
| NHTSA ID Number: | 11112065 |
|---|---|
| Consumer Location: | HUNTINGTOWN, MD |
| VIN: | 1FMDU74K84U**** |
TAKATA RECALL I WAS DRIVING ABOUT 5 MILES PER HOUR WHEN THE SIDE AIR BAGS DEPLOY ON THERE OWN MAKING A BIG BLAST WITHOUT BEEN INVOLVING IN ACCIDENT I DON'T KNOW WATT CAUSE THE AIR BAGS TO DEPLOY THIS COULD BEEN A BIG ACCIDENT IF I WAS DRIVING ON THE MAIN HIGHWAY AT NORMAL SPEED RESULTING IN POSSIBLE DEATH
| NHTSA ID Number: | 11099163 |
|---|---|
| Consumer Location: | WICHITA, KS |
| VIN: | 1FMZU64W34U**** |
IN 2004 FORD EXPLORER WITH V8, THE CRUISE CONTROL TURNS OFF ENGINE WHEN TRAVELING 35~45 MPH AND GOING DOWN A HILL OR DECLINE. THIS AFFECTS POWER STEERING AND BRAKES MAKING IT DIFFICULT TO CONTROL AND SLOW DOWN THE VEHICLE. THIS HAS HAPPENED REPEATEDLY FOR THE PAST 10 YEARS, SO I AM USED TO THIS DEFECT. MY WORKAROUND IS TO PUT THE VEHICLE IN NEUTRAL AND RESTART THE VEHICLE AND THEN CONTINUE.
| NHTSA ID Number: | 11097563 |
|---|---|
| Consumer Location: | HEPHZIBAH, GA |
| VIN: | **** |
I GET A STRONG SMELL OF ROTTEN EGGS WHEN DRIVING. IT ONLY HAPPENS WHEN I DRIVE FOR A LONG TIME. MY BACK HATCH IS CRACKING IN 3 OR MORE SPOTS I AM AFRAID THAT IT WILL PROBABLY FALL OFF AND CAUSE DAMAGE TO SOMEONE DRIVING BEHIND ME.
| NHTSA ID Number: | 11081189 |
|---|---|
| Consumer Location: | FOUR OAKS, NC |
| VIN: | 1FMZU73K04U**** |
TAKATA RECALL I HAD AN ACCIDENT ON HWY 701, I WENT OFF THE ROAD AND HIT A CEMENT CULVERT GOING 45MPH AND MY DRIVER SIDE AIRBAG DIDN'T DEPLOY I SUFFERED 2 SPINAL FRACTURES.
| NHTSA ID Number: | 11062592 |
|---|---|
| Consumer Location: | GLENVILLE, NY |
| VIN: | 1FMZU74W64U**** |
REAR GLASS LIFTGATE HINGE BROKE CAUSING GLASS TO FALL OUT OF POSITION. VEHICLE WAS STATIONARY AND LIFTGATE GLASS WAS BEING OPENED WHEN THE HINGE FAILED. THIS IS THE SECOND FORD EXPLORER THIS HAPPENED TO. THE FIRST ONE WAS A 2006 FORD EXPLORER.
| NHTSA ID Number: | 11057243 |
|---|---|
| Consumer Location: | WOODRUFF, SC |
| VIN: | 1FMZU73K44Z**** |
WELL WE JUST BOUGHT THIS EXPLORER AND JUST AS I HAVE READ FROM OTHERS ON THIS WEBSITE OUR EXPLORER IS DOING SIMILAR THINGS. SUCH AS SHIFTING IN REVERSE TAKES 3-7 SECONDS TO TAKE HOLD, GOING UP THE MOUNTAINS THE SUV HAD MAJOR KICKBACKS AND JERKS. I HAVE NOT TAKEN TO DEALERSHIP AS OF NOW. WILL MAKE AN APT. AND PUT RESULTS LATER.
| NHTSA ID Number: | 11048123 |
|---|---|
| Consumer Location: | BLAIRSVILLE, PA |
| VIN: | 1FMZU73E74U**** |
ALL FOUR SEALS WHERE LEAKING INCLUDING PINION SEALS. CLUNKING NOISE 40 TO 50MPH WHEN YOU LET GO OF THE GAS ,HOLDS BACK,HEATER GAUGE+MPH GAUGE DON'T WORK MOST.OF THE TIME.PAINT CHIPPING AWAY ALL OVER.REPLACED ALL SEALS 5 TIMES +YOKE CVHALF SHAFT. REPLACED FRONT DIFFERENTIAL STILL MAKING THE NOISE.POOR LIGHTING AT NIGHT.IT HAS A MISS FIRE GAVE IT A TUNEUP AND STILL IS DOING IT. RADIO VOLUME WON'T TURN DOWN IT GOES LOUDER WHEN TURNING DOWN.
| NHTSA ID Number: | 11046647 |
|---|---|
| Consumer Location: | SIOUX FALLS, SD |
| VIN: | 1FMDU74K84Z**** |
BRAKE LIGHTS CAME ON BY THEMSELVES, BOTH WHILE DRIVING AND AT A STANDSTILL. I COULD PULL THE ON THE BRAKE PEDDLE BUT WHEN I SHUT THE DOOR THE BRAKE LIGHTS WOULD COME ON. WHEN DRIVING IT MUST HAVE BEEN CONFUSING TO PEOPLE BEHIND ME THINKING I KEPT APPLYING THE BRAKES. I TOOK IT TO A SHOP TO HAVE THE BRAKE LIGHT SWITCH REPLACE AND FOUND THAT THERE WASN'T A REPLACEMENT SWITCH AVAILABLE AND A DIFFERENT ONE HD TO BE WIRED IN AT THE COST OF OVER $180.00.
