Components: ELECTRICAL SYSTEM EXTERIOR LIGHTING VISIBILITY
October 03, 2001
TBD
Condition
Run & Drive
Damage
Normal
Title
Clear
| Dynamic Head Restraints | Not Available |
|---|---|
| Head Restraint | Not Available |
| Advanced Belt Feature | Not Available |
| Adjustable Upper Belt Anchorage | Not Available |
| Seat Belt Reminder System | Not Available |
| Frontal Air Bag | Driver, Front Passenger |
|---|---|
| Knee | Not Available |
| Additional Air Bags | Not Available |
| Meets Side Air Bag Out-of-Position Requirements | Not Available |
| LATCH Locations | Not Available |
|---|---|
| Safety Power Windows (Anti-Pinch) | Not Available |
| Safety Power Windows (Anti-Pinch) locations | Not Available |
| NHTSA ID Number: | 10045731 |
|---|---|
| Consumer Location: | CORPUS CHRISTI, TX |
| VIN: | KM8SB82B01U**** |
ALTERNATOR/BATTERY PROBLEMS: LIGHTS DIM, WINDSHIELD WIPER DELAY CHANGES SPEED, ELECTRIC WINDOWS SLOW AT TIMES.*AK
| NHTSA ID Number: | 10045735 |
|---|---|
| Consumer Location: | CORPUS CHRISTI, TX |
| VIN: | KM8SB82B01U**** |
VEHICLE RATTLES AND SHAKES WHEN DRIVING IN CITY. NOISE APPEARS TO COME UNDER THE CARRIAGE. TAKEN SEVERAL TIMES TO THE DEALER AND THEY ARE UNABLE TO LOCATE THE SOURCE OF THE PROBLEM. HAVE A WRITTEN COMPLAIN WITH HYUNDAI.*AK
| NHTSA ID Number: | 766296 |
|---|---|
| Consumer Location: | GALENA, OH |
| VIN: | KM8SB82B01U**** |
OCCASIONALY AS I DRIVE AT NIGHT THE HEADLIGHTS WILL DIM, CLOCK WILL FLASH, AND THE WINDSHIELD WIPERS WILL SLOW DOWN BECAUSE THE ALERNATOR WILL NOT CHARGE THE BATTERY. OCCASIONALY WHEN I STOP AND TURN THE CAR OFF I WILL COME BACK OUT TO RESTART THE CAR AND IT WILL NOT START BECAUSE OF THE BATTERY BEING DEAD AND NOT BEING CHARGED BY THE ALTERNATOR. I HAVE ALREADY HAD THE BATTERY AND ALTERNATOR REPLACED ONCE ON 7/26/02 AND IT IS STARTING TO DO THE SAME THING AGAIN. I AM IN CONTACT WITH SEVERAL OTHER SANTA FE OWNERS AT WWW.SANTAFEFORUM.NET AND ALOT OF THEM ARE HAVING THE SAME PROBLEM.
| NHTSA ID Number: | 567188 |
|---|---|
| Consumer Location: | YAUCO, PR |
| VIN: | KM8SB82B01U**** |
ENGINE HESITATES. DEALER CHANGED SPARK PLUGS TWICE, OXYGEN SENSOR AND TRANSMISSION COMPUTER. AFTER REPLACEMENT VEHICLE BEGAN TO OVERHEAT AND STALLED OUT LOSING POWER. VEHICLE HAS BEEN AT DEALERSHIP 15 TIMES AND THEY ARE STILL NOT ABLE TO FIND THE PROBLEM. *TT
| NHTSA ID Number: | 11439998 |
|---|---|
| Consumer Location: | OZARK, MO |
| VIN: | Km8sc83d21u**** |
The rear trailing arm cracked in half causing my wife to run off the road11
| NHTSA ID Number: | 11430266 |
|---|---|
| Consumer Location: | FARGO, ND |
| VIN: | km8sc83d91u**** |
The contact's friend owns a 2001 Hyundai Santa Fe. The contact stated that while a friend was driving at approximately 55 MPH, the vehicle began to veer off to the right without warning and the driver began losing control of the vehicle. Despite the failure, the contact's friend was able to drive the vehicle to her home at slow speeds. Another friend was able to inspect the vehicle and discovered that the rear passenger’s side trailing arm had fractured due to severe corrosion. Upon investigation, the contact discovered NHTSA Campaign Number: 09V123000 (Suspension) which he linked to the failure. The dealer and the manufacturer were both notified of the failure and he was informed that his vehicle was not under recall. The vehicle had yet to be repaired. The failure mileage was unknown.
| NHTSA ID Number: | 11387403 |
|---|---|
| Consumer Location: | GROTTOES, VA |
| VIN: | KM8SC83031U**** |
MY WIFE WAS ACCELERATING TO 45 MPH, THE VEHICLE BEGAN TO SWERVE LEFT TO RIGHT RAPIDLY. THERE WAS NO WARNING INDICATOR ILLUMINATED. SHE COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. SHE NOTICED THAT THE REAR PASSENGER SIDE WHEEL WAS ALMOST TOUCHING THE INSIDE OF THE REAR FENDER. SHE WAS ABLE TO LIMP IT ABOUT A MILE HOME TO DRIVEWAY. SHE CONTACTED HYUNDAI & THEY TOLD HER TO TOW IT TO CLOSEST HYUNDAI DEALERSHIP & REAP SUSPENSION PROBLEM WILL BE FIXED UNDER RECALL. AFTER WE PAID TO HAVE IT TOWED TO DEALERSHIP IT WAS DIAGNOSED THAT THE REAR TRAILING ARM WAS CORRODED AND ALMOST BROKEN & NEEDED TO BE REPLACED. THE DEALER SERVICE TECHNICIAN CALLED MY WIFE THE NEXT DAY TO INFORM HER THAT HER SANTA FE REAR TRAILING ARMS HAD NOT BEEN REPLACED BY HYUNDAI. SHE IMMEDIATELY CALLED HYUNDAI TO SPEAK WITH PERSON THAT TOLD HER TO HAVE IT TOWED TO DEALERSHIP. HYUNDAI OPENED A CASE NUMBER FOR HER SANTA FE. HYUNDAI CALLED BACK COUPLE DAYS LATER SAYING THEY HAD RESEARCHED HER SANTA FE UNDER RECALL CAMPAIGN 090 AND THAT IT DID NOT QUALIFY BEING THAT IT HAD NOT REGISTERED WITHIN THE 20 SALT BELT STATES REQUIRED FOR RECALL. HYUNDAI CASE WORKER SAID THEY WERE NOT GOING TO REPAIR THE SANTA FE UNDER RECALL.& HYUNDAI WAS CLOSING THE CASE. AFTER A VERY EXTENSIVE SEARCH ON THE SANTA FE FRAME CORROSION RECALL SHE DISCOVERED THAT THE FRAME CORROSION RECALL HAD BEEN EXPANDED TO INCLUDE EVERY SANTA FE WITHIN THE 50 STATES, ALTHOUGH HYUNDAI DID NOT SEND NOTICES TO ANYONE UNLESS THE SANTA FE HAD BEEN REGISTERED IN THE 20 SALT BELT STATES. WITH THIS NEW INFO SHE HAS BEEN TRYING TO CONTACT THE HYUNDAI CASE WORKER TO RE-OPEN HER CASE. AS IT STANDS HER SANTA FE WAS TOWED TO HYUNDAI DEALERSHIP WHERE IT SITS IN BACK LOT UNTOUCHED & UNDRIVEABLE. AFTER CLOSER LOOK AT TRAILING ARMS BOTH SIDES ARE RUSTED COMPLETELY OUT.
| NHTSA ID Number: | 11325885 |
|---|---|
| Consumer Location: | FLORENCE, AL |
| VIN: | KM8SC83D01U**** |
GAS PUMP PROBLEM KEEPS CLICKING AND I'VE REPLACE MANY PARTY BUT STILL LIKE ITS FULL OF GAS BUT I BE ON EMPTY.CAR ALSO JERKS LIKE I'VE BEEN REAR ENDED WHILE DRIVING LIKE IT HAS TRANSMISSION PROBLEMS AND I'VE REPLACE TRANSMISSION 2 TIMES. GEARS ONLY WORK MANUAL IT'S LIKE THE CAR HAS A MIND OF ITS OWN .ALSO MY TIRE FLEW OFF MY CAR ON THE BACK AND HAD TO TAKE TO DEALER SHIP AND THEY WAS SAYING IT'S SOME PROBLEM THEY CAN'T HELP .
| NHTSA ID Number: | 11325011 |
|---|---|
| Consumer Location: | KANSAS CITY, KS |
| VIN: | KM8SC83DX1U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH, THE CONTACT HEARD AN ABNORMAL POPPING SOUND COMING FROM THE REAR OF THE VEHICLE. THE CONTACT DROVE BACK TO HER RESIDENCE WHERE HER HUSBAND INSPECTED THE VEHICLE. THE CONTACT'S HUSBAND DISCOVERED CORROSION ON THE REAR CONTROL ARM. DUE TO THE CORROSION, THE DRIVER'S SIDE REAR CONTROL ARM FRACTURED. NEITHER THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT LINKED HER FAILURE TO NHTSA CAMPAIGN NUMBER: 09V123000 (SUSPENSION) HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000. *LN*JB
| NHTSA ID Number: | 11317237 |
|---|---|
| Consumer Location: | BALTIMORE, MD |
| VIN: | KM8SB82B51U**** |
THERE'S A REALL ON THIS VEHICLE THAT I JUST PURCHASED THE DESCRIPTION SAYS: FRONT COIL SPRING PROTECTOR INSTALLATION HOW CAN THIS ISSUE BE RESOLVED? THIS ISSUE SHOULD BEEN TAKING CARE OF AND REPORTED TO YOU GUYS BUT OBVIOUSLY IT HASN'T. SO I NEED TO KNOW IS IT STILL AVAILABLE TO BE FREE OF CHARGE OR DO I HAVE TO COME OUT OF POCKET TO GET THIS REPAIRED? OR CAN I STILL GO TO A HYANDAI DEALER FOR FREE REPAIRS? I'M NOT SURE OF THE NOTIFICATION DATE. SO IN THE BOX BELOW I'LL PUT THIS YEAR AND DATE
| NHTSA ID Number: | 11290474 |
|---|---|
| Consumer Location: | LORTON, VA |
| VIN: | KM8SC83D61U**** |
OUR MECHANIC HAS IDENTIFIED SIGNIFICANT CORROSION TO THE DRIVER'S SIDE REAR TRAILING ARM, A SAFETY AND OPERATIONAL VULNERABILITY CONSISTENT WITH NHTSA SAFETY RECALL NOTICE 09V123000. THE NHTSA SAFETY RECALL OBSERVES THE DANGER OF THE REAR TRAILING ARM FRACTURING, AND INCREASING THE RISK OF A VEHICLE CRASH. WE HAVE CONTACTED THE LOCAL DEALERSHIP AND THE MANUFACTURER, HYUNDAI, ABOUT THE SAFETY VULNERABILITY, RESULTING FROM THE LATENT MANUFACTURING WEAKNESS. AS DETAILED IN THE ATTACHED FILE. THE DEALER SERVICE DEPARTMENT IS INDIFFERENT TO THE FAULTY VEHICLE PART AND SAFETY VULNERABILITY, AND NO RESPONSE HAS BEEN RECEIVED FROM THE MANUFACTURER. WE ARE ATTACHING PHOTOS OF THE REAR TRAILING ARM CORROSION CONSISTENT WITH THE MANUFACTURING FAILURE IDENTIFIED IN THE NHTSA SAFETY RECALL.
| NHTSA ID Number: | 11287666 |
|---|---|
| Consumer Location: | HARRISONBURG, VA |
| VIN: | KM8SC83D61U**** |
I HAVE BEEN HEARING A CLANKING SOUND SINCE I HAVE BOUGHT THE VEHICLE USED MID NOVEMBER 2019 . THE SOUND SEEMS TO BE COMING FROM THE BACK PASSANGER SIDE WHEEL AREA IT APPEARS TO BE GETTING WORSE AND FEELS LIKE THE BACK PASSANGER SIDE WHEEL IS ABOUT TO FALL OFF ANYTIME THE VEHICLE IS IN MOTION .AND LOOKS VERY RUSTED OUT
| NHTSA ID Number: | 11269840 |
|---|---|
| Consumer Location: | KANSAS CITY, KS |
| VIN: | KM8SC83DX1U**** |
WHEN GETTING GAS, THE PUMP ALWAYS 'CLICKS OFF' WHEN IM PUMPING GAS. DOES NOT MATTER HOW FULL. THE ONLY WAY TO ENSURE A FULL TANK IS TO CONTINUE PUMPING UNTIL GAS COMES OUT THE TOP OF THE FILLER NECK. THIS USUALLY MEANS OVERRIDING AS MANY AS 50 PUMP 'CLICK OFFS'. I HAVE SEEN OTHER SANTA FE OWNERS COMPLAINING ABOUT THE SAME PROBLEM OBVIOUSLY THIS IS A MANUFACTURING FLAW & NEEDS TO BE FIXED. THIS METHOD OF GETTING A FULL TANK IS NOT DESIRABLE AND WHAT'S THE POINT OF HAVING A 17 GALLON GAS TANK IF IT TAKES 45MINUTES TO FILL UP. THANK YOU.
| NHTSA ID Number: | 11246192 |
|---|---|
| Consumer Location: | VIBURNUM, MO |
| VIN: | KM8SC83D61U**** |
DRIVERS SIDE LOWER CONTROL ARM RUSTED OUT IT HAS 2 RECALLS ON IT BUT NOT THE CONTROL ARM WHY IF THE TRAILING ARMS ARE RUSTED IT SHOULD BE ADDED TO???????? STARTED MAKING NOISE NO WARNING WHILE DRIVEING 55 MPH HAPPENED ON 8/23/2019
| NHTSA ID Number: | 11161135 |
|---|---|
| Consumer Location: | SPIRIT LAKE, IA |
| VIN: | KM8SC83D51U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING 35 MPH, THE VEHICLE BEGAN TO SWERVE LEFT TO RIGHT RAPIDLY. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. THE CONTACT NOTICED THAT THE REAR DRIVER'S SIDE WHEEL WAS ALMOST TOUCHING THE INSIDE OF THE REAR FENDER. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO A NEARBY INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR TRAILING ARM WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS LATER TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER BECAUSE IT WAS EIGHTY MILES AWAY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.
| NHTSA ID Number: | 11141940 |
|---|---|
| Consumer Location: | KENT, WA |
| VIN: | KM8SC83D41U**** |
REAR DRIVER SIDE TRAILING ARM BADLY RUSTED.
| NHTSA ID Number: | 11084533 |
|---|---|
| Consumer Location: | WICHITA, KS |
| VIN: | KM8SC83D31U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT BOTH FRONT COIL SPRINGS FRACTURED WITHOUT WARNING AND HAD BEEN REPLACED BY THE DEALER (HYUNDAI EAST, 11200 E CENTRAL AVE, WICHITA, KS 67206, (316) 977-7800). IN ADDITION, WHILE DRIVING AT A LOW RATE OF SPEED, THE REAR LOWER CONTROL ARM FRACTURED ON THE DRIVER'S SIDE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT EXPERIENCED A FAILURE WITH THE CRANKSHAFT SENSOR. THE MANUFACTURER INDICATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL CAMPAIGNS. THE VEHICLE CONTINUED TO EXHIBIT THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.
| NHTSA ID Number: | 11053798 |
|---|---|
| Consumer Location: | BLOOMINGTON, MN |
| VIN: | KM8SB828B21**** |
I HAD BEEN DRIVING THE VEHICLE HOME AND NOTICED THE CAR WAS RUBBING AGAINST THE CAR. THE SUBFRAME HAS RUSTED SO MUCH THAT I CAN'T DRIVE IT. HAD TAKEN THE VEHICLE TO FIRESTONE. THEY SAID NOT TO DRIVE IT AND YOU SHOULD HAVE IT TOWED TO OUR HOUSE. THEY SAID THE TIRE WOULD FALL OFF OR WORSE. THEY WOULDN'T TOUCH IT. SO I HAD IT TOWED TO THE HYUNDAI DEALERSHIP. THEY TOLD ME THAT TO REPLACE THE SUB FRAME IN THE FRONT ON THE DRIVER'S SIDE, IT WOULD COST $2000. WHEN I TOWED THE VEHICLE TO HYUNDAI, THEY SAID IT COULD COST UP TO $5000. I COULDN'T AFFORD TO FIX IT. I THEN TOWED IT HOME AND IT IS SITTING IN MY GARAGE. I WISH I WOULD HAVE KNOW ABOUT THIS PROBLEM BEFORE I BOUGHT.
| NHTSA ID Number: | 11048240 |
|---|---|
| Consumer Location: | JONESBOROUGH, TN |
| VIN: | KM8SB82B11U**** |
REAR DRIVER SIDE SPRING RUSTED OUT CAUSING TIRE TO LEAN INTO CAR. ONLY BACKING OUT OF DRIVE WAY AT 2 MPH. WHY WAS ONLY RECALL SENT TO SO CALLED "SALT STATES"? I LIVE IN TENNESSEE AND SALT IS USED ON ROADS IN WINTER.
| NHTSA ID Number: | 11048246 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | KM8SB82B11U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 2 MPH, THE REAR DRIVER SIDE WHEEL LEANED INWARD INTO THE VEHICLE. IN ADDITION, THE CONTACT NOTICED THAT THE REAR COIL SPRING OF THE SUSPENSION WAS RUSTED AND CORRODED. FRIENDSHIP HONDA IN JOHNSON CITY, TENESSEE WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 108,000. *TT JOHNSON CITY HYUNDAI REPAIRED FOR FREE. TRADED IT IN 12/29/17. UPDATED 8/14/18*JB
| NHTSA ID Number: | 10972134 |
|---|---|
| Consumer Location: | GLEN COVE, NY |
| VIN: | KM8SC83D91U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR AN OIL CHANGE, IT WAS DIAGNOSED THAT THE SUBFRAME FAILED DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 126,000.
| NHTSA ID Number: | 10950082 |
|---|---|
| Consumer Location: | BINGHAMTON, NY |
| VIN: | KM8SC83D81U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT NOTICED A FUEL ODOR INSIDE AND OUTSIDE THE VEHICLE. WHEN RE-FUELING, THE FUEL LEAKED OUT OF THE FUEL TANK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
| NHTSA ID Number: | 10939003 |
|---|---|
| Consumer Location: | CANAAN, CT |
| VIN: | KM8SC83D81U**** |
SUBFRAME/ENGINE CRADLE ROT TO POINT OF SEPARATION, LOSS OF STEERING AND VEHICLE CONTROL. MY NEWLY LICENSED GRAND-DAUGHTER TOOK IT FOR A SHORT ABOUT TOWN DRIVE, NOT GETTING MORE THAN A QUARTER MILE BEFORE THE WHEEL SNAPPED OUT OF HER HANDS AND THE VEHICLE HEADED FOR THE CENTER LINE. SHE MANAGED TO GET IT TO THE SIDE OF THE ROAD. BOTH FRONT WHEELS WERE IN DIFFERENT DIRECTIONS, MOVEMENT FORWARD WAS SLOPPY. AWEFUL NOISES COMING FROM BELOW. FLUIDS LEAKING. I KNEW THERE WAS RUST UNDERNEATH BUT NOT SUCH GREATLY WEAKENED PARTS. IMG_6087.JPG
| NHTSA ID Number: | 10875188 |
|---|---|
| Consumer Location: | CINCINNATI, OH |
| VIN: | KM8SC83D81U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE'S LOWER FRAME CONTROL ARM WAS MAKING A CLICKING NOISE. THE DEALER DIAGNOSED THAT THE A FRAME NEEDED TO BE REPLACED; HOWEVER, THE BOLTS THAT HELD THE FRAME WERE RUSTED. THE A FRAME WAS NOT ABLE TO BE REMOVED AND THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE MANUFACTURER ISSUED A PREVIOUS RECALL THAT WAS DIRECTLY RELATED TO THE FAILURE; HOWEVER, THEY WERE UNABLE TO IDENTIFY THE RECALL NUMBER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 172,000.
| NHTSA ID Number: | 10871918 |
|---|---|
| Consumer Location: | BOWLING GREEN, KY |
| VIN: | **** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THE DRIVER'S SIDE REAR WHEEL TILTED LEAVING THE VEHICLE IMPAIRED. THE VEHICLE WAS TOWED TO A NEAR BY FIRESTONE WHERE THE FAILURE WAS ASSESSED BY THE TECHNICIAN. THE FAILURE WAS DIAGNOSED AS A FRACTURED REAR AXEL. THE CONTACT STATED THAT THE MANUFACTURE WAS NOTIFIED OF THE FAILURE AND NO REPAIRS WAS MADE. THE FAILURE MILEAGE WAS 17,000. THE VIN WAS NOT AVAILABLE.
| NHTSA ID Number: | 10851470 |
|---|---|
| Consumer Location: | HERMOSA BEACH, CA |
| VIN: | KM8SC83DX1U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CRANKSHAFT POSITION SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V030000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000.
| NHTSA ID Number: | 10846372 |
|---|---|
| Consumer Location: | HOUSTON, TX |
| VIN: | KM8SC83D91U**** |
V EHICLE CAUGH T ON FIRE IN MOTION CLAIM NUMBER 870190.
| NHTSA ID Number: | 10846159 |
|---|---|
| Consumer Location: | MACON, GA |
| VIN: | KM8SC83D21U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SUSPENSION AND SUBFRAME THAT THE SUSPENSION WAS MOUNTED TO WAS SEVERELY CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE SUBFRAME AND SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 184,215.
| NHTSA ID Number: | 10780757 |
|---|---|
| Consumer Location: | CAMDEN, OH |
| VIN: | KM8SC83D41U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTE FE. WHILE DRIVING 25 MPH, THE CONTACT HEARD A LOUD POP, THE VEHICLE'S WEIGHT SHIFTED, AND THE REAR DRIVER SIDE TIRE CAVED INTO THE WHEEL WELD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR DRIVER SIDE TRAILING ARM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 155,000.
| NHTSA ID Number: | 10749992 |
|---|---|
| Consumer Location: | LAWRENCEVILLE, NJ |
| VIN: | KM8SB82B71U**** |
I HAVE HAD TO REPLACE THE BALL JOINTS TWICE. THE FIRST TIME WAS SEVEN YEARS AGO AT ABOUT 40,000 MILES AND RECENTLY IN JUNE 2016 AT 84,000 MILES. SINCE IT IS A UNIQUE SUSPENSION WITHOUT ALIGNMENT ADJUSTMENTS, THE DESIGN COULD BE CAUSING UNUSUAL STRESS ON THE BALL JOINTS.
| NHTSA ID Number: | 10717420 |
|---|---|
| Consumer Location: | MASON, OH |
| VIN: | KM8SC83D91U**** |
WHILE DRIVING HOME WITH FAMILY IN VEHICLE THE CONTROL ARMS BROKE, BALL JOINTS BROKE AND THE SWAY BAR BROKE.
| NHTSA ID Number: | 10711759 |
|---|---|
| Consumer Location: | CLARKSBURG, MD |
| VIN: | KM8SC83D61U**** |
REAR TRAILING ON ON BOTH SIDES HAVE CORRODED THROUGH. DRIVER SIDE REAR CONTROL CASE HAS DISINTEGRATED, PASSENGER SIDE IS SEVERELY CORRODED. - MARCH 18, 2010: VEHICLE HAD SERVICE PREFORMED ON TO ADDRESS "RECALL #090 REAR TRAILING ARMS AND FRONT SUB-FRAME CORROSION TREATMENT", RUST PREVENTATIVE V AND PLUG KIT SERVICE PERFORMED BY DEALER. - MAY 16, 2012: VEHICLE HAD SUBFAME REPLACED DUE TO RUST HOLE AT RIGHT FRONT LOWER CONTROL ARM CONNECTION, REPLACEMENT OF RACK & PINION AND TRANSFER CASE FOR $2777. - DEC 12, 2014: VEHICLE HAD SERVICE PERFORMED TO ADDRESS "TSB# 14-01-141-1 - FRONT COIL SPRING PROTECTOR. THERE IS A FAULT WITH HOW THE RECALLS AND SERVICE REQUIREMENTS HAVE BEEN ISSUED WITH THIS VEHICLE. IF THE RECALL AND PRESCRIBED SERVICE WERE PROPERLY DONE, HAVING TO REPLACE THE FRONT SUB-FRAME JUST OVER 2 YEARS OF HAVING SERVICE TO PREVENT SUB-FRAME CORROSION PERFORMED WOULD NOT HAVE BEEN REQUIRED. THE SUB-FRAME WAS SO DAMAGED THAT THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. NOR WOULD 4 MONTHS AFTER HAVING RECALL SERVICE PERFORMED AND VEHICLE INSPECTED BY DEALER, THE REAR CONTROL CASE AND ARMS HAVE COMPLETELY FAILED MAKING THE CAR NOT ONLY UNSAFE TO DRIVE BUT NOT EVEN DRIVABLE NOW BECAUSE THE REAR DRIVER SIDE WHEEL IS POSITIONED AT AN ANGLE WITH STRUCTURAL SUPPORT.
| NHTSA ID Number: | 10704422 |
|---|---|
| Consumer Location: | MOBILE, AL |
| VIN: | **** |
THE EXTERIOR PAINTING ON MY VEHICLE IS OF POOR QUALITY. ABOUT 4 YEARS AGO, THE PAINT STARTED OXIDIZING IN MULTIPLE AREAS SUCH AS THE HOOD & ROOF- INITIALLY IN SMALL AREAS, BUT HAS NOW SPREAD TO COVER MOST OF THESE AREAS. I WAXED THE CAR AT LEAST 2X PER YEAR. THE PAINT JUST DOES NOT APPEAR TO HAVE BEEN OF A HIGH QUALITY. *TR
| NHTSA ID Number: | 10669329 |
|---|---|
| Consumer Location: | DETROIT, MI |
| VIN: | KM8SB82B51U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. ON A SECOND OCCASION, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 163,000. UPDATED 03/24/15*LJ
| NHTSA ID Number: | 10668693 |
|---|---|
| Consumer Location: | RAINELLE, WV |
| VIN: | KM8SC83D31U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING 55 MPH, THE VEHICLE VEERED TO THE RIGHT AND THE STEERING WHEEL SEIZED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,592.
| NHTSA ID Number: | 10658638 |
|---|---|
| Consumer Location: | HUXLEY, IA |
| VIN: | KM8SC83D21U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY CORRODED AND CAUSED DAMAGE TO THE FRONT TIRES. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V435000 (SUSPENSION). THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
| NHTSA ID Number: | 10643256 |
|---|---|
| Consumer Location: | SAINT XAVIER, MT |
| VIN: | KM8SC83D11U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 40 MPH, THE REAR OF THE VEHICLE SWAYED. THE CONTACT NOTICED THAT THE REAR END WAS LOWER THAN NORMAL. A CERTIFIED MECHANIC STATED THAT THE REAR-TRAILING ARM AND STRUTS WERE RUSTED. THE VEHICLE WAS TOWED TO THE DEALER AND REPAIRED. THE DETAILS OF THE REPAIR WERE UNKNOWN. THE CONTACT ALSO MENTIONED THAT THE FUEL TANK WAS PREVIOUSLY REPLACED DUE TO RUST. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
| NHTSA ID Number: | 10640234 |
|---|---|
| Consumer Location: | MOUNT BETHEL, PA |
| VIN: | KM8SC83D31U**** |
TL* THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE ATTEMPTING TO MAKE A LEFT, THE REAR TIRES TURNED RIGHT AND THE VEHICLE WENT SIDEWAYS BLOCKING TWO LANES. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRIVER AND PASSENGER SIDE TRAIL ARM WAS RUSTED AND CRACKED IN HALF. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V123000 (SUSPENSION). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,000.
| NHTSA ID Number: | 10637474 |
|---|---|
| Consumer Location: | BARBERTON, OH |
| VIN: | KM8SC83D91U**** |
TL*THE CONTACT OWNS A 2001 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE ENGINE STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000. DJR
| NHTSA ID Number: | 10629911 |
|---|---|
| Consumer Location: | MIDDLEBURGH, NY |
| VIN: | KM8SC83D71U**** |
HI, I'VE READ SEVERAL COMPLAINTS OVER A ISSUE THAT I'M STARTING TO HAVE AND THE OUT COMES HAS NOT BEEN GOOD AND I FEAR FOR MY FAMILY DRIVING IN THIS VEHICLE. I'M HEARING A SCRATCHY RUBBING SOUND IN THE REAR SO I JACKED IT UP TO FIND MY TRAIL ARMS ARE RUSTED SO BAD THEIRS HUGE HOLES IN THE TRAIL ARMS AND ROTOR COVER ARE RUSTED ALMOST OFF. I SURE DON'T WANT TO RECEIVE A CALL MY FAMILY HAS BEEN HURT IN A ACCIDENT SO IS WHY I'M CONTACTING YOU OVER THIS MATTER. I WOULD APPRECIATE TO BE CONTACTED TO KNOW WHAT I SHOULD DO BEFORE IT'S TO LATE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
