Components: STRUCTURE
May 01, 2017
TBD
Condition
Starts
Damage
Collision
Title
Clear
| Dynamic Head Restraints | Not Available |
|---|---|
| Head Restraint | Not Available |
| Advanced Belt Feature | Not Available |
| Adjustable Upper Belt Anchorage | Not Available |
| Seat Belt Reminder System | Not Available |
| Frontal Air Bag | Driver, Front Passenger |
|---|---|
| Curtain | Driver, Front Passenger, Rear Seat |
| Torso | Driver, Front Passenger |
| Knee | Not Available |
| Additional Air Bags | Not Available |
| Meets Side Air Bag Out-of-Position Requirements | Yes |
| LATCH Locations | Not Available |
|---|---|
| Safety Power Windows (Anti-Pinch) | Not Available |
| Safety Power Windows (Anti-Pinch) locations | Not Available |
| NHTSA ID Number: | 10985723 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | 5TETX22N66Z**** |
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, THE MECHANIC NOTICED THAT THE FRONT PASSENGER SIDE FRAME WAS CORRODED THROUGH WITH HOLES APPROXIMATELY THREE TO FOUR INCHES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE RECALL WAS CLOSED AND THE VEHICLE COULD NOT BE SERVICED. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.
| NHTSA ID Number: | 10497661 |
|---|---|
| Consumer Location: | MODESTO, CA |
| VIN: | 5TETX22N66Z**** |
MY SRS LIGHT TURNED ON AND I DON'T KNOW WHY. *TR
| NHTSA ID Number: | 11465630 |
|---|---|
| Consumer Location: | PALM COAST, FL |
| VIN: | 5TEUU42N36Z**** |
I recently bought this Tacoma used and just found out from my local mechanic that the frame is severely rusted and likely unsafe to drive. I immediately scheduled a frame inspection with Toyota. They confirmed that it was very unsafe to drive and gave me a quote of $14,711 to fix it. This is more than the value of the truck. Although Toyota acknowledged that there was a service campaign for rust issues on these trucks they said it had expired and there was nothing I could do.
| NHTSA ID Number: | 11451779 |
|---|---|
| Consumer Location: | KERNERSVILLE, NC |
| VIN: | 5TELU42N06Z**** |
Never received recall on frame, why wasn't I sent a recall and why don't dealership notify me when leaf springs were replaced?
| NHTSA ID Number: | 11442396 |
|---|---|
| Consumer Location: | NORTH BERWICK, ME |
| VIN: | 5TEUU42N76Z**** |
The universal joint on the intermediate steering shaft corrodes and seizes causing a potential problem steering. It is a serious safety issue in my opinion. It is an on-going issue.
| NHTSA ID Number: | 11442442 |
|---|---|
| Consumer Location: | HILLSBORO, WV |
| VIN: | 5teuu42n26z**** |
The contact owns a 2006 Toyota Tacoma. The contact stated while having the vehicle inspected by an independent mechanic, he was informed that there was severe corrosion to the sub-frame of the vehicle. Prior to the discovery, the contact had taken the vehicle to the dealer where the frame was sprayed with a rust inhibitor to prevent corrosion. Over the years, the contact had taken the vehicle back to the same dealer on multiple occasions to have the frame checked. On each visit, the contact was informed that the sub-frame was in good shape. The manufacturer was notified of the failure and informed him that the vehicle was out of warranty but offered no further assistance. The vehicle was not repaired. The failure mileage was approximately 109,000.
| NHTSA ID Number: | 11442092 |
|---|---|
| Consumer Location: | LOGAN, UT |
| VIN: | 5telu42n86z**** |
The contact owns a 2006 Toyota Tacoma. The contact stated that his father had taken the vehicle to a dealer to have NHTSA Campaign Number: 14V604000 (Suspension) serviced. Upon inspection, his father was informed that the recall could not be performed due to the extensive corrosion on the frame of the vehicle. He was also informed that the vehicle was unsafe to drive and was given an estimate of $16,000 for the repair. The manufacturer was then notified of the failure and offered no assistance. The vehicle had yet to be repaired. The failure mileage was approximately 128,000.
| NHTSA ID Number: | 11441376 |
|---|---|
| Consumer Location: | OLYMPIA, WA |
| VIN: | 5TEUU42N26Z**** |
My airbag warning light went off and the horn ceased functioning as well. The dealer charged me $170 to diagnose the problem as a broken spiral cable in the steering wheel. I asked about a recall for this part as there are plenty of other Toyota models with a recall for this same part. I was told that this particular VIN was not part of any campaign (yet). Are they actually different parts on the RAV4 and 4Runners or the same part?? There are plenty of documented failures and testimonials about the Tacoma issue but no recall??? Where does pressure need to come from to initiate one? Another $575 to fix it, what is a glaring safety issue.
| NHTSA ID Number: | 11440256 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | 5teuu42nx6z**** |
The mechanic noticed rust the frame was rusty so recommend I take it to a metal shop to get an estimate for re-welding the frame and they are hesitant to even work on it because of how corroded it is. The cab is almost detached from the frame and the support above the rear axle is about to snap in half.
| NHTSA ID Number: | 11439268 |
|---|---|
| Consumer Location: | NEW CONCORD, OH |
| VIN: | 5TEPX42N26Z**** |
My frame rusted and broke into where spring hanger bolts to the frame. They are saying n was recalled but time has ran out but I did not receive a recall notice as we moved to another area of the state ( Ashtabula) where we bought a shop for our oilfield business then we moved to ( Cambridge ) and are now renting our first home from my daughter who bought it in New Concord. Sad thing is we had it to repair shop and had new steering, power steering pump, new front axles and no one said hey you should look at this frame it is rotten and I have a picture I can send you if you'd like.So it is totally broke into and the spring hanger is not attached and pushed the bed up and the driver nearly wrecked and we had to haul it back on a trailer.
| NHTSA ID Number: | 11431384 |
|---|---|
| Consumer Location: | HARTSVILLE, SC |
| VIN: | 5TELX22N46Z**** |
The contact owns a 2006 Toyota Tacoma. The contact stated that upon inspection it was discovered that the entire subframe had sustained severe rust and corrosion damage. The cause of the failure was not determined. The vehicle was not repaired. The vehicle was taken to the local dealer who advised that the vehicle was too damaged to drive. The manufacturer was not yet notified. The failure mileage was 97,000. The VIN was invalid.
| NHTSA ID Number: | 11430473 |
|---|---|
| Consumer Location: | FISHERS, IN |
| VIN: | 5TELU42N16Z**** |
The contact owns a 2006 Toyota Tacoma. The contact stated while driving at various speeds, the vehicle would drift and pull to the left. The vehicle was taken to an independent mechanic who diagnosed that the subframe had experienced severe rusting and corrosion damage and that the structural integrity of the vehicle had been compromised. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 140,000.
| NHTSA ID Number: | 11429733 |
|---|---|
| Consumer Location: | COLUMBUS, OH |
| VIN: | 5teUU42N96Z**** |
The contact owns a 2006 Toyota Tacoma. The contact stated that he was made aware that the sub frame of the vehicle was rusted badly when the vehicle was taken to the dealer for faulty brake lines. The dealer informed the contact that they could not perform the brake line repair due to the sub frame rust. The contact was informed that the sub frame needed to be replaced. The contact stated that another dealer Germain Toyota of Columbus (5711 Scarborough Blvd, Columbus, OH 43232) had sealed and plugged the frame which caused the frame to rust from water damage. The vehicle was later taken to an independent mechanic for the brake line repair and remained at the mechanic. The manufacturer was not made aware of the failure. The failure mileage was approximately 220,000.
| NHTSA ID Number: | 11423252 |
|---|---|
| Consumer Location: | HASBROUCK HEIGHTS, NJ |
| VIN: | 5TEMU52N56Z**** |
The contact owns a 2006 Toyota Tacoma. The contact received notification of NHTSA Campaign Number: 14V604000 (Suspension). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The part was available for repair. The contact had not experienced a failure. Parts distribution disconnect.
| NHTSA ID Number: | 11422991 |
|---|---|
| Consumer Location: | LEHIGHTON, PA |
| VIN: | 5TEUU42N66Z**** |
On June 26, 2021, I took my 2006 Toyota Tacoma to Bennett Toyota for regular maintenance. As part of the inspection, I was notified that the "Frame very rusted, perforation may begin on cab mounts in the next year" and the Service Advisor told me that my car would be unsafe to drive in a year or two. I told the Service Advisor that in 2015, I received a recall notice from Toyota regarding frame rust and took my 2006 Toyota Tacoma to Bennett Toyota to address the issue. On April 22, 2015, Bennett Toyota provided "Corrosion-Resistant Compound (CRC) Application; Remove Rust - Clean Frame - No Rust Perforation Found". Again on March 29, 2018, I requested that Bennett Toyota inspect the frame for corrosion perforation and was notified that "No Significant Perforation Found". The Service Advisor stated that the extended warranty had expired and there was nothing Bennett Toyota could do to address the rusted frame. I then called Toyota and opened case# 210628002014 to request the rusted frame be addressed/replaced/repaired and was told that the extended warranty had expired and there was nothing that Toyota would do to address the issue. I have a Toyota Tacoma with a known issue that is quickly becoming unsafe to drive and have no way to repair/replace the rusted frame.
| NHTSA ID Number: | 11422270 |
|---|---|
| Consumer Location: | WILMINGTON, NC |
| VIN: | 5TEJU62N66Z**** |
The contact owns a 2006 Toyota Tacoma. The contact stated that after the vehicle was taken in for maintenance, it was discovered that the vehicle had severe rusting and corrosion to the subframe and the recall repair for campaign number 14V604000 (Suspension) could not be performed. The cause of the failure was not determined. The manufacturer was not notified of the failure. The failure mileage was 107,000.
| NHTSA ID Number: | 11419083 |
|---|---|
| Consumer Location: | BALTIMORE, MD |
| VIN: | 5teku72n86z**** |
The frame of the car is rusted and deemed unsafe. Due to the rust of the frame the car could be unsupported and cause potential harm to the driver and others on the road. The problem has been identified by a dealer and manufacturer. There were no warnings on the car about this.
| NHTSA ID Number: | 11417376 |
|---|---|
| Consumer Location: | MESA, AZ |
| VIN: | 5TEJU62NX6Z**** |
Driver side air bag is not operational. Horn doesn't work. There was a spiral cable assembly recall for the 2006 Toyota Tacoma as well as air bag recall. My Vin number was not included but my vehicle is affected. Will this be corrected by Toyota. My vehicle only has 125,000 miles.
| NHTSA ID Number: | 11417472 |
|---|---|
| Consumer Location: | WALKER, LA |
| VIN: | 3TMJU62N56M**** |
THE CHECK ENGINE LIGHT WILL NOT GO OFF. A TOYOTA INDEPENDENT SERVICE/REPAIR FACILITY CHECKED EVERYTHING AND SAID IT IS ELECTRICAL BOARD PROBLEM. I REC'D A SAFETY RECALL LETTER FROM TOYOTA STATING THERE IS A MALFUNCTION INDICATOR LAMP CAUSING THE CHECK ENGINE LIGHT TO STAY ON. IT STATES I WILL RECEIVE A 2ND NOTIFICATION WHEN REMEDY IS AVAILABLE THAT I HAVE NOT REC'D. THEY WANT ME TO PAY THE DEALER (APPROX. 300-400 DOLLARS) THEN SEND DOCUMENTS OF REPAIR TO TOYOTA CORP FOR REIMBURSEMENT! I DO NOT HAVE THAT KIND OF MONEY TO WAIT AND SEE IF I WILL BE REIMBURSED. WHY ARE THEY DRAGGING THEIR FEET NOT SENDING AN ACTUAL RECALL THAT THEY WILL PAY THEIR DEALERS AFTER THEY PERFORM THE WORK? WHY IS THIS RECALL NOT NOTED ABOVE. ARE THEY TRYING TO NOT HAVE TO DO ANYTHING? IN RED, THE LETTER STATES "THIS IS AN IMPORTANT SAFETY RECALL:" BUT THE TOYOTA DEALER "TEAM TOYOTA" KNEW NOTHING ABOUT IT,SAID THEY COULD CHECK AND FIX, BUT WOULD HAVE TO PAY FOR IT THEN MAYBE BE REIMBURSED BY TOYOTA BUT THEY COULDN'T SAY I WOULD BE. CAN YOU HELP WITH THIS?? MY EMAIL IS [XXX] THANK YOU [XXX] (RETIRED DON'T HAVE ACCESS TO SEND DOCUMENTS,I COULD TAKE PICTURE WITH PHONE AND SEND TO PHONE #) INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
| NHTSA ID Number: | 11405623 |
|---|---|
| Consumer Location: | TEMPE, AZ |
| VIN: | 5TEKU72N96Z**** |
REAR DIFFERENTIAL OIL LEAK. THERE HAD BEEN A RECALL IN THE 2016 TOYOTA TACOMA BUT MY 2006 HAS THE SAME PROBLEM STARTING YEARS AGO. I DID NOT KNOW IT WAS LEAKING UNTIL I TOOK IT TO THE DEALERSHIP.
| NHTSA ID Number: | 11405639 |
|---|---|
| Consumer Location: | TEMPE, AZ |
| VIN: | 5TEKU72N96Z**** |
BROKEN REAR LEAF SPRING ASSEMBLY: THIS PROBLEM HAS BEEN KNOWN IN TOYOTAS SINCE THE FIRST GENERATION TACOMAS BUT WORSE IN THE SECOND GENERATION. THE LEAF SPRINGS AREN'T PROPERLY EQUIPPED TO HANDLE THE TOWING CAPACITY OUTLINED IN THE OWNER'S MANUAL AND WILL CRACK, FLATTEN, OR BREAK UNDER TOO MUCH WEIGHT. I WAS TOLD BY THE DEALER THAT IT NEEDED REPLACED ON 11/7/2016. TOYOTA ADDRESSED THIS ISSUE IN 2007 BY RELEASING A TSB STATING THAT THEY'D REPLACE THE SPRINGS ON ANY SECOND-GEN TACOMA STILL UNDER WARRANTY. I BOUGHT MINE IN 2006. I HAVE LIVED IN THE SAME LOCATION FOR OVER 25 YEARS.*DT CONSUMER DISCOVERED DEALERSHIP DID PERFORM THE REPAIRS AND WOULD LIKE COMPLAINT TO BE CANCELLED.*JB
| NHTSA ID Number: | 11404605 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | 5TELU42N16Z**** |
THIS SHOULD BE A MANDATORY RECALL. THIS IS DANGEROUS AND SHOULD BE LOOKED AT THAT WAY PEOPLE HAVE HAD THEIR FRAMES BROKEN IN HALF. THE WORST DAMAGE ON MINE IS DRIVER'S SIDE UP FRONT THERE IS ALSO RUST NEAR THE REAR MY TRUCK RECENTLY HAD REAR SPRINGS REPLACED ON A RECALL. THEY SHOULD HAVE NOTICED IT THEY SAID NOTHING ABOUT IT, THE FRONT TIRES HAVE BEEN REPLACED SEVERAL TIMES AT THE SAME DEALERSHIP SHOULD HAVE BEEN EASY TO NOTICE THE DAMAGE AT FRONT DIDN'T MENTION IT. THANK YOU TONY BAGGETT.
| NHTSA ID Number: | 11397855 |
|---|---|
| Consumer Location: | LONG BRANCH, NJ |
| VIN: | 5TEMU52N16Z**** |
THE FRAME HAS RUSTED AND THE DEALER TOLD ME THEY COULDN'T REPLACE FOR FREE THE WHOLE FRAME IS RUSTED AND WHERE THE SUSPENSION IS HOLDING WITH THE NUTS ARE STARTING TO LOOK VERY DANGERS ALSO IT HAS A GOOD AMOUNT OF WHOLE AND I WAS TOLD I HAD TO PAY TO REPLACE WHICH IS HORRIBLE BECAUSE IT'S NOT MY FAULT I LIVE IN AN AREA WHERE SALT IS USED IT'S TOYOTA FAULT SINCE THEY DIDN'T USE THE RIGHT METAL OR WHATEVER FOR THE FRAME AND NOW I'M STUCK WITH A 2006 TOYOTA TACOMA WITH 119,000 MILES THAT I DON'T FEEL SAFE USING WHEN DRIVING
| NHTSA ID Number: | 11389279 |
|---|---|
| Consumer Location: | JACKSONVILLE, FL |
| VIN: | **** |
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY AT 10 MPH, THE FUEL TANK STRAPS FAILED CAUSING THE FUEL TANK TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE LOCAL DEALER ARLINGTON TOYOTA LOCATED AT 10939 ATLANTIC BLVD, JACKSONVILLE, FL 32225 JACKSONVILLLE FL. WHO DIAGNOSED THAT THE SUBFRAME HAD SUSTAINED SEVERE RUSTING AND CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000. THE VIN WAS NOT AVAILABLE.
| NHTSA ID Number: | 11386259 |
|---|---|
| Consumer Location: | BOILING SPRINGS, SC |
| VIN: | 3TMLU42N76M**** |
WHITE PAINT CHIPPING AND PEELING ALL OVER TRUCK WHITE PAINT
| NHTSA ID Number: | 11383003 |
|---|---|
| Consumer Location: | TOPEKA, KS |
| VIN: | 5TELU42N06Z**** |
06 TACOMA FRAME THAT HAS RUSTED THROUGH THE FRAME WHERE THE FRONT AND BACK SECTION ARE WELDED TOGETHER. ALSO ON THE ARM TO THE SHOCK HAS RUSTED THROUGH. THE VEHICLE WAS INSPECTED IN 2018 AND THE LEAF SPRINGS WERE REPLACED AND WAS TOLD THE REST OF THE FRAME WAS OK. I ONLY FOUND THE PROBLEM WHEN THE EXHAUST BRACKET WAS HANGING DOWN, WHICH THE WELD BROKE FROM THE RUST.
| NHTSA ID Number: | 11377753 |
|---|---|
| Consumer Location: | ARLINGTON, TX |
| VIN: | 5TETU62N96Z**** |
IT IS HARD TO PULL OUT AND THE BELT IS NOT TIED ENOUGH. I DID BRING TO THE DEALER FOR RECALL, BUT THEY DONT CONFIRM THAT THEY FIX/REPLACE OR NOT. THE CONSUMER STATED THE SEAT BELT WAS REPAIRED UNDER RECALL BUT, STILL FAILED. *JS
| NHTSA ID Number: | 11376208 |
|---|---|
| Consumer Location: | PRINCEVILLE, HI |
| VIN: | 5TEKU72N76Z**** |
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS TAKEN TO SERVCO AUTO (2477 ULU MAIKA ST, LIHUE, HI 96766, (877) 292-9755) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE LEAF SPRINGS WERE RUSTED AND THE RECALL REPAIR COULD NOT BE COMPLETED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT ADDITIONAL REPAIRS MAY BE COMPLETED BY THE VEHICLE OWNER. THE FAILURE MILEAGE WAS 147,250.
| NHTSA ID Number: | 11363703 |
|---|---|
| Consumer Location: | KING GEORGE, VA |
| VIN: | 5TEUU42N56Z**** |
WHEN PRESSING THE BREAK PEDAL TO STOP THE TRUCK, THE BREAK PEDAL WILL GO STRAIGHT TO THE FLOOR. THE BREAKS WILL NOT ENGAGE THE TRUCK WILL NOT STOP. PUMPING THE BREAKS DOES NOT BRING THE BREAKS BACK. NO DASHBOARD LIGHT COME ON. THE BREAKS WILL BE GONE FOR ANY LENGTH OF TIME AND THEN WILL START WORKING AGAIN. STOPPING THE TRUCK AND TURNING IT ON AND OFF WILL NOT BRING THE BREAKS BACK. ONLY WAY TO STOP THE TRUCK WHEN THE BREAKS GO OUT IS WITH THE PARKING BREAK. THIS IS AN INTERMITTENT PROBLEM SOMETIMES THEY WORK SOMETIMES THEY DON'T. WHEN THE BREAKS WOULD GO OUT IT WAS ALWAYS AT SPEEDS OVER 40MPH AND ON HIGHWAYS COUNTRY ROADS AND ALWAYS ON A RETURN TRIP AFTER THE CAR HAD BEEN TURNED OFF ONCE. AFTER THE FIRST INCIDENT TOOK IT TO TOYOTA DEALERSHIP THEY SAID IT WAS BAD FRONT BREAKS AND FRONT LEFT BEARING, REPLACED BOTH TOOK IT HOME TWO WEEKS LATER BREAKS WENT OUT AGAIN ON HIGHWAY WHILE TRYING TO STOP AT A LIGHT, BROUGHT IT BACK TO TOYOTA DEALERSHIP, BREAKS WERE STILL OUT. THEY SAID NOTHING WAS WRONG EXCEPT I HEATED UP MY FRONT BREAKS WHILE TRYING TO STOP, AND THAT THEY WERE NOW COOL AND I SHOULD NOT HAVE THE PROBLEM AGAIN. I ASKED THEM TO CHECK ALL THE OTHER COMPONENTS OF THE BREAKING SYSTEM THEY SAID THEY WERE FINE. AT NO TIME DID ANY LIGHT COME ON ON THE DASHBOARD. I PICKED IT UP FROM DEALERSHIP THERE WAS NO BREAKS ON THE TRUCK. SO I TOWED HOME. HAD BREAK BOOSTER AND CHECK VALVE REPLACED RE-FLUSHED BREAKS. PROBLEM ACCURED AGAIN, TOOK IT TO LOCAL MECHANIC WHO BELIEVES IT'S THE ABS MODULAR. HAVE BEEN TRYING TO REPLACE ABS MODULAR SINCE MAY OF 2020, TOYOTA SAYS THERE IS A BACKORDER OF ABS SYSTEMS CAN NOT GIVE AN ETA OF WHEN THEY WILL BE BACK IN STOCK.THE PROBLEM MIGHT BE UNKNOWN BUT THE MECHANIC IS PRETTY SURE IT IS THE ABS MODULAR.
| NHTSA ID Number: | 11362256 |
|---|---|
| Consumer Location: | JACKSONVILLE, FL |
| VIN: | 5TELU42N66Z**** |
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V388000 (VEHICLE SPEED CONTROL) AND 14V604000 (SUSPENSION). THE CONTACT CALLED AND TOOK THE VEHICLE TO THE ARLINGTON TOYOTA LOCATED AT 10939 ATLANTIC BLVD, JACKSONVILLE, FL 32225, AND AFTER TWO WEEKS, THE TECHNICIAN STATED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED PRIOR TO THE RECALL REPAIRS BEING PERFORMED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 136,100.
| NHTSA ID Number: | 11360140 |
|---|---|
| Consumer Location: | PLYMOUTH, MA |
| VIN: | 5TELU42N36Z**** |
BODY ROT DUE TO CORROSION OF MANUFACTURE DEFECT. TOYOTA SPRAYED THE BODY UNDER COST BUT AGAIN COMING OFF AND BODY ROT THROUGH OUT VEHICLE.
| NHTSA ID Number: | 11354472 |
|---|---|
| Consumer Location: | POQUOSON, VA |
| VIN: | 5TEMU52N66Z**** |
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE SUBFRAME WAS RUSTED AND THE VEHICLE WOULD NOT PASS STATE INSPECTION. THE VEHICLE WAS TAKEN TO GLOUCESTER TOYOTA LOCATED AT 6357 GEORGE WASHINGTON MEMORIAL HWY, GLOUCESTER, VA 23061, AND THE CONTACT WAS INFORMED BY THE TECHNICIAN THAT THE VEHICLE WAS SUBJECTED TO NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS REPAIRED. THE TECHNICIAN ALSO INFORMED THE CONTACT ABOUT AN UNKNOWN FRAME RECALL THAT HAD EXPIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT, OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 126,000.*JB
| NHTSA ID Number: | 11351791 |
|---|---|
| Consumer Location: | MAHOPAC, NY |
| VIN: | 5TEMU52N56Z**** |
I HAVE A BLACK-COLORED 2006 TOYOTA TACOMA PICKUP TRUCK. FOR MANY YEARS, I'VE WONDERED WHY THE PAINT ON THE HOOD CHIPPED OFF IN TINY CIRCLES, UNLIKE ANY OTHER MODEL VEHICLE THAT I HAVE EVER OWNED. RECENTLY, I WAS SHOCKED TO SEE HOW BADLY RUSTED A SECTION OF THE ROOF OF MY CAB WAS. I CHECKED ONLINE TO SEE IF OTHERS WERE HAVING A SIMILAR ISSUE AND FOUND PEOPLE COMPLAINING OF THIS SEEMED TO OWN PICK-UPS THAT WERE ALSO PAINTED BLACK, AND WERE ALSO 2006 MODELS. THE RUST PATTERNS SEEMED SIMILAR IN EVERY PICTURE I VIEWED, A PORTION OF THE ROOF ABOVE THE DRIVERS SIDE, RUSTED THE LENGTH FROM NEAR THE FRONT WINDSHIELD AREA TO NEAR THE BACK OF THE CAB. IN MY OPINION, AND BASED ON THE PICTURES OF SIMILAR INSTANCES I'VE VIEWED ONLINE, THERE SEEMS TO POSSIBLY BE SOME COMPELLING EVIDENCE OF A DEFICIENCY IN THE PAINTING METHOD OR MATERIAL USED ON THIS COLOR/YEAR TRUCK. IS THERE A RECALL OR SERVICE BULLETIN IN THE WORKS? I BELIEVE TOYOTA NEEDS TO ACKNOWLEDGE THIS ISSUE AS SOMETHING DOES NOT SEEM QUITE RIGHT AND THAT THEY SHOULD ADDRESS THESE ANOMALIES IN AN EFFORT TO REACH A FAIR RESOLUTION? BTW, THE REAR BUMPER'S EXCEPTIONALLY RUSTED OUT TOO, AND THE PLASTIC HEADLIGHT COVERINGS ON THIS MODEL HAVE CLOUDED UP WORSE THAN I HAVE EVER SEEN ON ANY OTHER VEHICLE MAKE, AS MOST OTHER HEADLIGHTS THAT I AM FAMILIAR WITH ARE MADE OF GLASS. (SEE ATTACHED PICTURES)
| NHTSA ID Number: | 11342455 |
|---|---|
| Consumer Location: | LIHUE, HI |
| VIN: | 5TELU42N86Z**** |
RUSTY FRAME, I WAS JUST TOLD BY MY LOCAL TOYOTA THAT MY FRAME RECALL EXPIRED LAST JANUARY 2019. I WAS NOT AWARE THAT A RECALL EXPIRES, NOW MY DAUGHTER HAS TO DRIVE AN UNSAFE VEHICLE. THERE IS ONE SPOT ON THE FRAME WHERE I CAN PUT MY WHOLE HAND INTO. PLEASE ADVISE.
| NHTSA ID Number: | 11337398 |
|---|---|
| Consumer Location: | BELTON, SC |
| VIN: | 5TEMU52N96Z**** |
EXCESSIVE CORROSION AND RUSTED THROUGH FRAME THAT IS UNABLE TO SUPPORT WEIGHT OF VEHICLE. HAD A BRAKE LINE BUST DUE TO BEING RUSTED OR CORRODED OUT. ALSO SUSPENSION SHOWS EXCESSIVE RUST AND CORROSION. COOLING LINES CORRODED. POWER STEERING LINES CORRODED. TRANSMISSION LINES CORRODED. ANY METAL LINE IS THAT'S ATTACHED TO THIS VEHICLE ARE CORRODED. AND ALL BRACKETS AND HARDWARE ATTACHED TO FRAME AND EVEN THE METAL PULLEYS ALL EXCESSIVELY CORRODED.
| NHTSA ID Number: | 11337237 |
|---|---|
| Consumer Location: | EAGLE, ID |
| VIN: | 5TELU42N36Z**** |
TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE CLOCKSPRING FAILED TO FUNCTION AS DESIGNED, WHICH CAUSED THE AIR BAG WARNING LIGHT TO ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V092000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 173,170.
| NHTSA ID Number: | 11328316 |
|---|---|
| Consumer Location: | PENSACOLA, FL |
| VIN: | 5TETX22N16Z**** |
PREVIOUS OWNER REMOVED DRIVER AIRBAG AND SEAT BELT HARNESS (WEBBING ONLY) DUE TO RECALLS. THE PART THAT CAUSED THE RECALL FOR THE SEAT BELT IS STILL ATTACHED TO THE VEHICLE. LOCAL DEALERSHIP WILL NOT HONOR RECALL. CONTACTED TOYOTA (CASE #[XXX]) AND THEY TOO WILL NOT HONOR THE RECALL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
| NHTSA ID Number: | 11326005 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | 5TEKU72N06Z**** |
WHEN INSPECTING THE LEAF SPRING REPLACEMENT FROM A RECALL, FOUND THE FRAME CORRODED TO THE POINT THAT IT WILL FAIL. (SEE PHOTO). TOYOTA HAD A RECALL ON THESE FRAMES AND THIS TRUCK FELL UNDER THE GUIDELINES.WHEN I CONTACTED TOYOTA THEY SAID THIS WAS AN EXTENDED WARRANTY AND HAD EXPIRED.SAID THEY SENT NOTIFICATION WHICH I NEVER RECEIVED. *TR
| NHTSA ID Number: | 11325342 |
|---|---|
| Consumer Location: | MORGANTOWN, WV |
| VIN: | 5TENX22N56Z**** |
THIS VEHICLE IS COVERED IN THE TOYOTA RUSTY FRAME LAWSUIT. AS SUCH, IT HAS BEEN INSPECTED BY 2 DIFFERENT DEALERS AND DEEMED NOT TO NEED A FRAME REPLACEMENT BOTH TIMES. IT WAS TREATED WITH CRC. ITS LAST INSPECTION WAS IN NOVEMBER OF 2018. ON SUNDAY, MAY 17TH, 2020, THE FRAME BROKE AT THE FRONT CROSS-MEMBER CAUSING THE LEFT FRONT LOWER CONTROL ARM TO SEPARATE AND STEERING THE VEHICLE/CONTROLLING THE VEHICLE BECAME NEAR IMPOSSIBLE. FORTUNATELY FOR ME, THIS HAPPENED IN A PARKING LOT BACKING OUT OF A PARKING SPACE AND TURNING LEFT (IN REVERSE AT LOW SPEED) AFTER A FULL 2 WEEKS OF DRIVING IN THE MOUNTAINS OF WEST VIRGINIA. I QUESTION ALL INSPECTIONS OF FRAMES BEING PERFORMED WITHIN THE TOYOTA DEALER NETWORK AND HOPE THAT NOBODY HAS THIS FAILURE WHILE THEY ARE DRIVING AT SPEED AS THE RESULTS WILL BE CATASTROPHIC. *TR
| NHTSA ID Number: | 11323175 |
|---|---|
| Consumer Location: | LANCASTER, KY |
| VIN: | 5TELU42N66Z**** |
TL* THE CONTACT OWNED A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE ENTIRE SUBFRAME WAS SEVERELY RUSTED. THE VEHICLE WAS TAKEN TO TOYOTA SOUTH (961 FOUR MILE RD, RICHMOND, KY 40475, (859) 624-1313) AND THE CONTACT WAS INFORMED OF TOYOTA WARRANTY ENHANCEMENT PROGRAM ZH6 HOWEVER, THE WARRANTY PERIOD WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 262,000.
