Components: ELECTRICAL SYSTEM FORWARD COLLISION AVOIDANCE
November 01, 2020
TBD
Condition
Unknown
Damage
Mechanical
Title
Clear
| Dynamic Head Restraints | Standard |
|---|---|
| Head Restraint | Not Available |
| Advanced Belt Feature | Not Available |
| Adjustable Upper Belt Anchorage | Not Available |
| Seat Belt Reminder System | Not Available |
| Frontal Air Bag | Driver, Front Passenger |
|---|---|
| Curtain | Driver, Front Passenger, Rear Seat |
| Torso | Driver, Front Passenger |
| Knee | Not Available |
| Additional Air Bags | Not Available |
| Meets Side Air Bag Out-of-Position Requirements | Not Available |
| LATCH Locations | Not Available |
|---|---|
| Safety Power Windows (Anti-Pinch) | Not Available |
| Safety Power Windows (Anti-Pinch) locations | Not Available |
| NHTSA ID Number: | 11373691 |
|---|---|
| Consumer Location: | WATERFLOW, NM |
| VIN: | YV1MS682742**** |
HAVING A COOLANT LEAKAGE, CRASH MODE AND SAFETY ALARM SYSTEM CHECK KEEPS COMING ON...WHEN CRASH MODE COMES ON...CAR JUST SHUTS OFF.
| NHTSA ID Number: | 11265371 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | **** |
TL* THE CONTACT OWNS A 2004 VOLVO S40 EQUIPPED WITH COOPER ZEON RS3-A TIRES, SIZE: 205/55/16R (NA). THE CONTACT HEARD A LOUD HUMMING NOISE COMING FROM THE TIRES. THE INSIDE OF THE TREAD HAD A LINE AND THE CONTACT NOTICED DAMAGE OR AN OPENING. AN INDEPENDENT MECHANIC CONFIRMED THAT THE TIRES WERE SEPARATING AT THE TREAD LINE. AN UNKNOWN TIRE DEALER STATED THAT THE TIRES WERE NOT UNDER WARRANTY AFTER THE TIRES HAD BEEN OWNED FOR OVER THREE YEARS. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE FAILURE MILEAGE WAS 145,000. THE TIRE FAILURE MILEAGE AND VIN WERE UNKNOWN.
| NHTSA ID Number: | 11100343 |
|---|---|
| Consumer Location: | CHARLOTTE, NC |
| VIN: | YV1VS27544F**** |
NO COLLISION. SRS LIGHT HAS BEEN COMING ON SINCE 2007. DEALERSHIP HAS REPLACED WIRING, AIR BAGS AND NOTHING HELPS. SRS LIGHT COMES ON EVERY 7 TO 12 MONTHS. THIS HAS BEEN GOING ON FOR 11 YEARS.
| NHTSA ID Number: | 11084482 |
|---|---|
| Consumer Location: | FRENCH CAMP, CA |
| VIN: | YV1VS27534F**** |
THE KEY DOES NOT TURN ALL THE WAY TO TURN THE IGNITION - IT'S LOCKED AFTER TURNING I AND II (NOT TO III). I HAD TO HAVE THE CAR TOWED. I COULD HAVE BEEN STRANDED IN AN UNSAFE AREA. I CALLED VOLVO CUSTOMER SERVICE, BUT I WAS TOLD IT'S NOT UNDER WARRANTY ANYMORE. I WENT TO YOUTUBE AS TO HOW I COULD FIX IT AND FOUND OUT QUITE A FEE S40 OWNERS HAVE SIMILAR PROBLEMS. I WAS TOLD THAT THE COST TO FIX THIS WOULD RUN ABOUT $1000. I FOUND A WAY TO GET AROUND MAKING IT WORK BY REMOVING THE STEERING COVER, PULL THE IGNITION SWITCH WITH A SCREW DRIVER. WITHOUT THE KEY ON THE IGNITION, IT STILL POSES A SAFETY ISSUES BECAUSE WHAT IF THE STEERING LOCKS WHILE I AM DRIVING? ANOTHER ISSUE IS THE SUSPENSION: THE CAR FEEL AS IF IT'S FALLING APART. TWICE WE SPENT OVER A THOUSAND FOR EACH OCCURRENCE. I'M QUITE CERTAIN THERE HAVE A FEW COMPLAINTS ON SIMILAR ISSUES. I WOULD APPRECIATE IT VERY MUCH IF YOU COULD KEEP ME IN THE LOOP IF ISSUES COME UP ON THIS MAKE, MODEL AND YEAR WE STILL OWN AND KEEP ON DRIVING. I ALMOST FORGOT, ONE OF THE HEAD LIGHTS DOES NOT AND EVEN SIMPLE REPLACING WITH ONE AFTER A BULB, STILL DOES NOT WORK. I GUESS IT NEEDS A TRIP TO THE DEALERSHIP FOR THEM TO FIGURE IT OUT. AFTER ALL, SUDDEN HEADLIGHT FAILURE WHILE DRIVING AT NIGHT, IS A SERIOUS SAFETY ISSUE. THANK YOU IN ADVANCE FOR CONSIDERING TO TAKE MY ISSUES.
| NHTSA ID Number: | 10940120 |
|---|---|
| Consumer Location: | BRIDGEWATER, MA |
| VIN: | YV1MS682942**** |
THE ISSUE OF NO HEADLIGHTS (LOW-BULB FAILURE) IS DANGEROUS & EXPENSIVE. NOR IS THERE A VIABLE PERMANENT REPAIR AS THE "LOW-BULB FAILURE" ALWAYS RE-OCCURS & HAS BEEN AN ONGOING PROBLEM FOR ME SINCE MY CAR WAS NEW. SUDDENLY HAVING NO HEADLIGHTS CAUSES A SERIOUS & IMMEDIATE SAFETY ISSUE FOR OCCUPANTS OF THE CAR & FOR ONCOMING TRAFFIC WHO CAN'T SEE A CAR WITHOUT HEADLIGHTS. IT CAN BE 1 HEADLIGHT OR BOTH THAT FAIL WITHOUT WARNING; LEAVING NO TIME TO BRING A VEHICLE TO A STOP SAFELY. THE EXPERIENCE IS FRIGHTENING & DANGEROUS IN THOSE TENSE MOMENTS IT TAKES TO STOP A MOVING CAR ON THE ROAD WITHOUT HEADLIGHTS. I HAVE EVEN BEEN ISSUED A VIOLATION TICKET FROM THE POLICE FOR EQUIPMENT FAILURE DESPITE NUMEROUS REPAIR BILLS THAT I KEEP IN THE CAR. AFTER REPEATED ATTEMPTS AT GETTING VOLVO TO FIX THIS ISSUE, I REPORTED THE PROBLEM TO NHTSA SEVERAL YEARS AGO BUT WAS TOLD THERE HAD NOT BEEN ENOUGH COMPLAINTS ABOUT THE HEADLIGHT FAILURE PROBLEM TO DO ANYTHING. NOW, YEARS HAVE GONE BY AND I AM STILL DEALING WITH A CAR THAT IS ESSENTIALLY A DAYTIME ONLY CAR AS IT IS NOT SAFE TO DRIVE AFTER DARK DUE TO THE UNPREDICTABLE LOSS OF HEADLIGHTS. EACH TIME THE HEADLIGHTS FAIL I BRING THE CAR FOR SERVICE AND EVERY TIME THE HEADLIGHT FAILS AGAIN AND AGAIN WITHIN WEEKS OF THE "REPAIR". REPAIR COST ARE IN THE $500 RANGE. THERE IS NO RECOURSE FOR THE REPAIRS OTHER THAN TO TRY SOMETHING NEW. IT HAS BECOME A PROBLEM THAT IS WIDELY KNOWN AT REPAIR SHOPS; AND AFTERMARKET REPAIR KITS ARE NOW COMMON BECAUSE VOLVO HAS IGNORED THE ISSUE STATING THAT THERE IS NOT A PROBLEM TO ME. IT IS EASY TO FIND MANY CAR OWNERS WITH THE SAME ISSUE AND FRUSTRATIONS ON THE INTERNET AS WELL AS SUITS BROUGHT AGAINST OTHER AUTO MANUFACTURERS FOR THE WIDE-SCALE FAILURE OF THESE USELESS, DEFECTIVE HEADLIGHTS. NHTSA SHOULD PROHIBIT THESE HEADLIGHTS AND FORCE ACTION FOR THOSE RESPONSIBLE TO ADDRESS THIS KNOWN SAFETY ISSUE. *TR
| NHTSA ID Number: | 10908871 |
|---|---|
| Consumer Location: | VIENNA, VA |
| VIN: | YV1MS382042**** |
BRAKE PEDAL IS TOO CLOSE TO ACCELERATOR PEDAL. WHENEVER I OPERATE THE GAS PEDAL, THE SIDE OF MY SHOE ALSO ACTIVATES THE BRAKE. THE PROBLEM IS AGGRAVATED BY THE CENTER TUNNEL CARPET INTRUDING ON THE MINIMAL ACCELERATOR PEDAL SPACE.
| NHTSA ID Number: | 10903603 |
|---|---|
| Consumer Location: | CASTLE ROCK, WA |
| VIN: | YV1MS682842**** |
MY VEHICLE DOORS LOCK UP AND CAN'T BE UNLOCKED DUE TO FAULTY LOCKS. NO WAY TO GET DOOR OR DOORS TO UNLOCK. WHICH CAN CAUSE DEATH IF INVOLVED IN A ROLL OVER, SUBMERGED, OR ANY MAJOR ACCIDENTS. IT CAN BE ANY DOOR ON THE VEHICLE. ON MINE IT'S MY REAR PASSENGER DOOR WHICH MY CHILD SITS NEXT TOO IN HER CAR SEAT. I'VE READ MANY OTHER VOLVOS HAVE THIS ISSUE AND VERY COSTLY TO REPAIR. VOLVO SHOULD BE RESPONSIBLE AS I HAVE BEEN TOLD BY A VOLVO DEALER MECHANIC THAT THESE S40 ARE VERY KNOWN TO HAVE THIS ISSUE. FOR MY EXPERIENCE OF THIS HAPPENING IS JUST DRIVING HOME AND PARKING. TRIED TO GET MY DAUGHTER OUT AND IT WOULD NOT UNLOCK. THE KEY FAUBOURG, THE POWER LOCK SWITCH AND TRIED PULLING ON HANDLE AND NOTHING UNLOCKS THIS DOOR. I READ THAT THE LOCK ACTUATORS ARE THE CAUSE OR ITS THE WIRING HARNESS. I ALSO HAVE THIS PROBLEM IN THE TRUNK. ONLY THE KID NAPPED CORD WORKS TO GET THE TRUNK TO OPEN. PLEASE GET VOLVO TO FIX ALL THERE ACTUATORS BEFORE KIDS OR ADULTS GET TRAPPED AND KILLED CAUSE OF THEIR NEGLIGENCE
| NHTSA ID Number: | 10875785 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | YV1MS382X42**** |
CAR IS STALLING OUT WHILE DRIVING DOWN THE ROAD ENGINE LIGHT CAME ON WHEN PUT ON MACHINE ERROR GIVEN IS FUEL PRESSURE. THE FUEL PRESSURE WAS CHECKED AND WAS AT CORRECT PRESSURE FOR THE CAR. I HAVE REPLACED FUEL CENSER AND CAR RAN FINE FOR 2 DAYS THEN SAME ISSUE WITH SAME ERROR THE FUEL CONTROLLER HAS A CORRODED PEN I TRIED TO CALL VOLVO THEY ARE TELLING ME THERE IS NOTHING THEY CAN DO WHEN I CAN CLEARLY SEE THE YEAR MAKE AND MODEL HAVE HAD A RECALL FOR THE EXACT ISSUE THAT I AM HAVING WITH THIS CAR. THE RECALL NUMBER IN YOUR SYSTEM IS 08V033000 I NORMALLY WOULD JUST GET THE CAR FIXED BUT THIS IS A MAJOR ISSUE IT SEEMS THE LOCATION OF THE CONTROLLER NEEDS TO BE MOVED TO PREVENT THIS FROM HAPPENING AGAIN. THIS IS A CAR MY 16 YEAR OLD DAUGHTER DRIVES SO YOU CAN UNDERSTAND MY CONCERN WITH VOVLO NOT WANTING TO CORRECT THIS
| NHTSA ID Number: | 10794522 |
|---|---|
| Consumer Location: | Unknown |
| VIN: | YV1VS27574F**** |
I GOT NEW CAR IN NOV 2003 OF THE YEAR 2004 MODEL. IT FEELS LIKE ONE HAS TO PUT FOOT ON BRAKES ALL THE WAY TO APPLY. IT IS PROGRESSIVELY GETTING WORSE. IN DEC 2005, WHILE EXISTING FROM HIGHWAY WE MEET AN ACCIDENT AS IT DID NOT STOP WHERE IT WAS SUPPOSE TO STOP. VOLVO DEALER TOP THE BREAK FLUID DURING MAINTENANCE. BUT DID NOT SOLVE THE PROBLEM. WE GOT NEW BRAKE PADS FROM VOLVO DEALER AND CHANGED ALONG WITH BRAKE DISCS IN 2009. BUT, IT DID NOT SOLVE THE PROBLEM. IN THE MORNING, IT WILL NOT BREAK UNLESS ONE HAS TO PUT FOOT ON PEDAL FEW TIMES. AGAIN IN 2015 WE GOT BRAKE PADS FROM OTHER AUTO PART SHOP OF HIGH QUALITY BUT IT DOES NOT SOLVE THE PROBLEM. IN ADDITION, I SMELL GAS BUT COULD NOT LOCATE ANY LEAK OF FUEL. ALSO, STEERING WHEEL IS VERY HARD AND WE TOOK TO VOLVO FEW TIMES BUT IT IS THE SAME.
| NHTSA ID Number: | 10681587 |
|---|---|
| Consumer Location: | HUMBLE, TX |
| VIN: | YV1MS382142**** |
TL* THE CONTACT OWNS A 2004 VOLVO S40. THE CONTACT STATED THAT THE ACCELERATOR PEDAL AND THE BRAKE PEDAL BECAME DIFFICULT TO DEPRESS. ALSO, THE CONTACT MENTIONED THAT DUE TO THE PROXIMITY OF THE PEDALS, THE BRAKE PEDAL WAS INADVERTENTLY DEPRESSED WHEN APPLYING THE ACCELERATOR PEDAL. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
| NHTSA ID Number: | 10681175 |
|---|---|
| Consumer Location: | PLYMOUTH, MN |
| VIN: | YV1MS682X42**** |
TL* THE CONTACT OWNS A 2004 VOLVO S40. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PEM WAS FAULTY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 100,625. UPDATED 04/07/15*LJ UPDATED 11/3/2015*JS
| NHTSA ID Number: | 10652766 |
|---|---|
| Consumer Location: | EAST STROUDSBURG, PA |
| VIN: | YV1MS382342**** |
I JUST BROUGHT THE CAR FROM JCL AUTO SALES IN ALLENTOWN PA AT THE END OF AUGUST AND MY CHECK ENGINE CONTINUES TO COME ON. *TR
| NHTSA ID Number: | 10641123 |
|---|---|
| Consumer Location: | HARDWICK, VT |
| VIN: | YV1MS682642**** |
FOR THE PAST TWO MORNINGS MY CAR HAS NO BRAKES WHEN I FIRST START MY CAR, ONCE I HAVE BEEN DRIVING FOR A FEW MINUTES IT'S OKAY, BUT FIRST THING THE PAST TWO MORNINGS I HAVEN'T HAD BRAKES! *TR
| NHTSA ID Number: | 10597709 |
|---|---|
| Consumer Location: | NORTH CANTON, OH |
| VIN: | YV1MS382X42**** |
TL* THE CONTACT OWNS A 2004 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE ENGINE STALLED. THE CHECK ENGINE AND BATTERY INDICATORS ILLUMINATED WHEN THE FAILURE OCCURRED, AND THE VEHICLE VEERED TO THE RIGHT. THE CONTACT PULLED THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE OCCURRED TWICE. THE MANUFACTURER WAS NOT NOTIFIED AND ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 08V033000 (FUEL SYSTEM, GASOLINE). A DIAGNOSTIC TEST INDICATED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE FAILURE DID NOT RECUR. THE FAILURE MILEAGE WAS 118,600. ..UPDATED 08/11/14 *BF THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. UPDATED 08/21/2014 *JS
| NHTSA ID Number: | 10485192 |
|---|---|
| Consumer Location: | CLIFTON PARK, NY |
| VIN: | YV1MS382042**** |
TL* THE CONTACT OWNS A 2004 VOLVO S40. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED WITHOUT WARNING. THE DEALER WAS CONTACTED AND ADVISED HIM THAT THE OCCUPANT WEIGHT SENSOR MAY HAVE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED HIM A 10 PERCENT COUPON. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. THE CURRENT MILEAGE WAS APPROXIMATELY 110,000.
